Introduction 4Instrument Cluster 12Warning lights and chimes 12Gauges 17Entertainment Systems 19AM/FM stereo 19AM/FM Stereo single CD/MP3 system 21Aux
These are some of the symbols you may see on your vehicle.Vehicle Symbol GlossarySafety AlertSee Owner’s GuideFasten Safety Belt Airbag - FrontAirbag
WARNING: Rear facing child seats should NEVER be placed infront of an active airbag.2. Pull down on the shoulder beltand then grasp the shoulder belta
5. To put the retractor in theautomatic locking mode, grasp theshoulder portion of the belt and pulldownward until all of the belt isextracted and a c
10. Before placing the child in theseat, forcibly move the seat forwardand back to make sure the seat issecurely held in place. To checkthis, grab the
(called the “seat bight”) and one (1) top tether anchor located behindthat seating position. Your vehicle is not equipped with the lower anchorpoints
Once the child safety seat has been installed using the safety belt, youcan attach the top tether strap.Perform the following steps to install a child
3. Clip the tether strap to theanchor.If the tether strap is clippedincorrectly, the child safety seat maynot be retained properly in theevent of a co
If the safety seat is not anchored properly, the risk of a child beinginjured in a collision greatly increases.If your child restraint system is equip
Booster seats should be used until you can answer YES to ALL of thesequestions when seated without a booster seat:• Can the child sit all the way back
• High back booster seatsIf, with a backless booster seat,you cannot find a seating positionthat adequately supports yourchild’s head, a high back boo
If the booster seat slides on the vehicle seat, placing a rubberized meshsold as shelf or carpet liner under the booster seat may improve thisconditio
Vehicle Symbol GlossaryPower WindowsFront/RearPower Window LockoutChild Safety DoorLock/UnlockInterior LuggageCompartment ReleasePanic Alarm Engine Oi
For proper care of soiled safety belts, refer to Interior in the Cleaningchapter.WARNING: Failure to inspect and if necessary replace thesafety belt a
NOTICE TO UTILITY VEHICLE AND TRUCK OWNERSUtility vehicles and trucks handledifferently than passenger cars inthe various driving conditions thatare e
Power is supplied to all four wheels through a transfer case or powertransfer unit. 4WD vehicles allow you to select different drive modes asnecessary
• Narrower – to provide greatermaneuverability in tight spaces,particularly in off-road use.As a result of the above dimensionaldifferences, SUVs and
government test course. For example, a tire graded 150 would wear oneand one-half (11⁄2) times as well on the government course as a tiregraded 100. T
• Tire Identification Number (TIN): A number on the sidewall ofeach tire providing information about the tire brand andmanufacturing plant, tire size
At least once a month and before long trips, inspect each tire and checkthe tire pressure with a tire gauge (including spare, if equipped). Inflateall
To check the pressure in your tire(s):1. Make sure the tires are cool, meaning they are not hot from drivingeven a mile.If you are checking tire press
the valve stem. Inspect the tire sidewalls for cracking, cuts, bruises andother signs of damage or excessive wear. If internal damage to the tire issu
U.S. DOT Tire Identification Number (TIN)Both U.S. and Canada Federal regulations require tire manufacturers toplace standardized information on the s
WARNING LIGHTS AND CHIMESWarning lights and gauges can alert you to a vehicle condition that maybecome serious enough to cause expensive repairs. A wa
WARNING: When mounting replacement tires and wheels, youshould not exceed the maximum pressure indicated on thesidewall of the tire to set the beads w
• Do not run over curbs or hit the tire against a curb when parkingWARNING: If your vehicle is stuck in snow, mud, sand, etc., donot rapidly spin the
• Rear-wheel drive (RWD)vehicles/Four-wheel drive(4WD)/All-wheel drive (AWD)vehicles (front tires at top ofdiagram)Sometimes irregular tire wear can b
Information on “P” type tiresP215/65R15 95H is an example of atire size, load index and speedrating. The definitions of theseitems are listed below. (
Note: You may not find this information on all tires because it is notrequired by federal law.Letter rating Speed rating - mph (km/h)M 81 mph (130 km/
11. Maximum Load: Indicates the maximum load in kilograms andpounds that can be carried by the tire. Refer to the Safety ComplianceCertification Label
Additional information contained on the tire sidewall for “LT” typetires“LT” type tires have some additionalinformation beyond those of “P”type tires;
Information on “T” type tires“T” type tires have some additionalinformation beyond those of “P”type tires; these differences aredescribed below:T145/8
TIRE PRESSURE MONITORING SYSTEM (TPMS)Each tire, including the spare (ifprovided), should be checkedmonthly when cold and inflated tothe inflation pre
following two conditions: (1) This device may not cause harmfulinterference, and (2) This device must accept any interference received,including inter
Check fuel cap: Illuminates whenthe fuel cap may not be properlyinstalled. Continued driving withthis light on may cause the serviceengine soon indica
When your temporary spare tire is installedWhen one of your road tires needs to be replaced with the temporaryspare, the TPMS system will continue to
Low tire pres-sure warninglightPossiblecauseCustomer action requiredFlashing warninglightSpare tirein useYour temporary spare tire is in use. Re-pair
SNOW TIRES AND CHAINSWARNING: Driving too fast for conditions creates the possibilityof loss of vehicle control. Driving at very high speeds forextend
your vehicle, familiarize yourself with the following terms for determiningyour vehicle’s weight ratings, with or without a trailer, from the vehicle’
Example only:Cargo Weight – includes all weight added to the Base Curb Weight,including cargo and optional equipment. When towing, trailer tongue load
GAWR (Gross Axle Weight Rating) – is the maximum allowableweight that can be carried by a single axle (front or rear). Thesenumbers are shown on the S
• Example only:WARNING: Exceeding the Safety Compliance Certification Labelvehicle weight rating limits could result in substandard vehiclehandling or
GCW (Gross Combined Weight) – is the weight of the loaded vehicle(GVW) plus the weight of the fully loaded trailer.GCWR (Gross Combined Weight Rating)
WARNING: Exceeding any vehicle weight rating limitation couldresult in serious damage to the vehicle and/or personal injury.Steps for determining the
to transport the cement to your home? If you and your friend eachweigh 220 lb. (99 kg), the calculation would be: 1400 - (2 x 220) - (12x 100) = 1400
Airbag readiness: If this light failsto illuminate when the ignition isturned to on, continues to flash orremains on, contact your authorizeddealer as
Follow these guidelines to ensure safe towing:• Do not tow a trailer until your vehicle has been driven at least1,000 miles (1,600 km).• Consult your
SuperCab 4x2Powertrain Maximum GCWR - lb(kg)Maximum trailerweight - lb (kg)2–Door Payload Package 1 without Jump Seat2.3L w/manualtransmission4800 (21
SuperCab 4x2Powertrain Maximum GCWR - lb(kg)Maximum trailerweight - lb (kg)4–Door Payload Package 1 with Jump Seat2.3L w/manualtransmission4800 (2177)
SuperCab 4x2 SportPowertrain Maximum GCWR - lb(kg)Maximum trailerweight - lb (kg)2–Door Payload Package 1 without Jump Seat4.0L w/manualtransmission70
SuperCab 4x4Powertrain Maximum GCWR -lb (kg)Maximum trailerweight - lb (kg)2–Door without Jump Seat4.0L w/manualtransmission7000 (3175) 3120 (1415)4.0
WARNING: Towing trailers beyond the maximum recommendedgross trailer weight exceeds the limit of the vehicle and couldresult in engine damage, transmi
HitchesFor towing trailers up to 2,000 lb (907 kg), use a weight-carrying hitchand ball which uniformly distributes the trailer tongue loads through t
WARNING: Do not connect a trailer’s hydraulic brake systemdirectly to your vehicle’s brake system. Your vehicle may nothave enough braking power and y
• To aid in engine/transmission cooling and A/C efficiency during hotweather while stopped in traffic, place the gearshift lever in P (Park)(automatic
Vehicles equipped with a manual transmission:Before you tow your vehicle:• Release the parking brake.• Move the gearshift to the neutral position.• Tu
WARNING: Never remove the coolant reservoir cap while theengine is running or hot.AdvanceTrac威/traction control:Illuminates when theAdvanceTrac威/tract
STARTINGPositions of the ignition1. Accessory — allows the electricalaccessories such as the radio tooperate while the engine is notrunning.2. Lock —
WARNING: Do not start your vehicle in a closed garage or inother enclosed areas. Exhaust fumes can be toxic. Always openthe garage door before you sta
If starting a vehicle with a manualtransmission:• Make sure the parking brake isset.• Press and hold the clutch pedalto the floor, then put thegearshi
1. Turn the key to 4 (on) withoutturning the key to 5 (start). If thereis difficulty in turning the key,rotate the steering wheel until thekey turns f
WARNING: Failure to follow engine block heater instructionscould result in property damage or physical injury.WARNING: To reduce the risk of electrica
• Finally, have the engine block heater system checked during your falltune-up to be sure it’s in good working order.How to use the engine block heate
has continuous vibration or shudder in the steering wheel while braking,the vehicle should be inspected by an authorized dealer.The ABS operates by de
Parking brakeApply the parking brake wheneverthe vehicle is parked. To set theparking brake, press the parkingbrake pedal down until the pedalstops.Th
ADVANCETRAC姞 WITH ROLL STABILITY CONTROL™ (RSC姞)STABILITY ENHANCEMENT SYSTEMYour vehicle is equipped with the AdvanceTrac威 with RSC威 system. TheAdvanc
WARNING: If a failure has been detected within theAdvanceTrac威 with RSC威 system, the stability control light willilluminate steadily and you may hear
Anti-theft system: Flashes whenthe SecuriLock威 passive anti-theftsystem has been activated.Speed control (if equipped):Illuminates when the speed cont
Traction control system (TCS)Traction control is a driver aid feature that helps your vehicle maintaintraction of the wheels, typically when driving o
• Entering a paved road from a gravel road, or vice versa• Cornering while towing a heavily loaded trailer (refer to Trailertowing in the Tires, Wheel
If you switch off the AdvanceTrac威with RSC威 system, the stabilitycontrol off light will illuminatesteadily. Pressing the AdvanceTrac威with RSC威 button
STEERINGTo help prevent damage to the power steering system:• Never hold the steering wheel at its furthest turning points (until itstops) for more th
PREPARING TO DRIVEWARNING: Utility vehicles have a significantly higher rolloverrate than other types of vehicles.WARNING: In a rollover crash, an unb
If you cannot move the gearshift lever out of P (Park) with the ignitionin the on position and the brake pedal pressed, it is possible that a fusehas
AUTOMATIC TRANSMISSION OPERATION (IF EQUIPPED)Driving with a 5–speed automatic transmission (if equipped)This vehicle is equipped with an adaptive tra
D (Drive) with OverdriveThe normal driving position for thebest fuel economy. Transmissionoperates in gears one through five.D (Drive) without Overdri
If your vehicle gets stuck in mud or snowIf your vehicle gets stuck in mud or snow, it may be rocked out byshifting between forward and reverse gears,
Do not drive with your foot resting on the clutch pedal or use theclutch pedal to hold your vehicle at a standstill while waiting on ahill. These acti
GAUGESSpeedometer: Indicates thecurrent vehicle speed.Engine coolant temperaturegauge: Indicates engine coolanttemperature. At normal operatingtempera
Reverse1. Make sure that your vehicle is ata complete stop before you shiftinto R (Reverse). Failure to do somay damage the transmission.2. Move the g
FOUR-WHEEL DRIVE (4WD) OPERATION (IF EQUIPPED)WARNING: For important information regarding safe operationof this type of vehicle, see Preparing to dri
Shifting between 2H (2WD High) and 4H (4WD High)• Move the 4WD control between 2H and 4H at a stop or any forwardspeed.Note: Do not perform this opera
steering and braking control of your vehicle, you must have all fourwheels on the ground and they must be rolling, not sliding or spinning.Basic opera
Do not rock the vehicle if the engine is not at normal operatingtemperature or damage to the transmission may occur.Do not rock the vehicle for more t
Power is supplied to all four wheels through a transfer case. On 4WDvehicles, the transfer case allows you to select 4WD when necessary.Information on
If the transmission, transfer case or front axle are submerged in water,their fluids should be checked and changed, if necessary.Driving through deep
Descend a hill in the same gear youwould use to climb up the hill toavoid excessive brake applicationand brake overheating. Do notdescend in neutral;
Maintenance and modificationsThe suspension and steering systems on your vehicle have been designedand tested to provide predictable performance wheth
ROADSIDE ASSISTANCEGetting roadside assistanceTo fully assist you should you have a vehicle concern, Ford MotorCompany offers a complimentary roadside
Trip odometer: Registers the miles(kilometers) of individual journeys.Press the button once until TRIPappears in the display (thisrepresents the trip
Owner Guide portfolio in the glove compartment. In Canada, the card isfound in the Warranty Guide in the glove compartment.U.S. Ford, Mercury and Linc
The fuel pump shut-off switch islocated on the right side of thepassenger footwell, behind the fusepanel door.To reset the switch:1. Turn the ignition
Standard fuse amperage rating and colorCOLORFuseratingMinifusesStandardfusesMaxifusesCartridgemaxifusesFuse linkcartridge2A Grey Grey — — —3A Violet V
The fuses are coded as follows:Fuse/RelayLocationFuse AmpRatingPassenger Compartment FusePanel Description1 5A Instrument panel dimmer switch2 10A Tra
Fuse/RelayLocationFuse AmpRatingPassenger Compartment FusePanel Description9 5A Cluster air bag indicator10 10A Cluster (run/start), 4x4 module(run/st
Fuse/RelayLocationFuse AmpRatingPassenger Compartment FusePanel Description30 5A Power mirrors31 20A Front park lamps, Rear parklamps, License plate l
If the battery has been disconnected and reconnected, refer to theBattery section of the Maintenance and Specifications chapter.2.3L engine (if equipp
Fuse/RelayLocationFuse AmpRatingPower Distribution BoxDescription10 — Not used11 30A** Powertrain control module (PCM)relay12 — Not used13 30A** Blowe
Fuse/RelayLocationFuse AmpRatingPower Distribution BoxDescription38 7.5A* Trailer tow (right turn)39 15A* PCM power40 — Not used41 10A* Automatic tran
4.0L engines (if equipped)The high-current fuses are coded as follows:Fuse/RelayLocationFuse AmpRatingProtected Circuits1 40A** Passenger compartment
AUDIO SYSTEMSAM/FM stereo (if equipped)WARNING: Driving while distracted can result in loss of vehiclecontrol, accident and injury. Ford strongly reco
Fuse/RelayLocationFuse AmpRatingProtected Circuits15 — Not used16 — Not used17 40A** Anti-lock brake system (ABS) module18 — Not used19 — Not used20 —
Fuse/RelayLocationFuse AmpRatingProtected Circuits43 20A* A/C relay coil, IAC, Mass air flowsensor, Heated exhaust gas oxygensensor, Catalyst module s
WARNING: The use of tire sealants may damage your tirepressure monitoring system (TPMS) and should not be used.However, if you must use a sealant, the
• Use commercial car washing equipment• Try to repair the dissimilar spare tireUse of one of the dissimilar spare tires listed above at any one wheell
Stopping and securing the vehicle1. Park on a level surface, activatehazard flashers and place gearshiftlever in P (Park) (automatictransmission) or 1
• One wheel nut wrench. Press thebutton and slide together.2. If equipped, unlock and removethe spare tire carrier lock from therear access hole locat
5. With the spare tire on the ground,remove the retainer from the sparetire.If equipped with a tether, perform the following additional steps:6. Lift
WARNING: Do not attempt to change a tire on the side of thevehicle close to moving traffic. Pull far enough off the road toavoid the danger of being h
• RearWARNING: To lessen therisk of personal injury, donot put any part of your bodyunder the vehicle while changing atire. Do not start the engine wh
Stowing the flat/spare tireNote: Failure to follow spare tire stowage instructions may result infailure of cable or loss of spare tire.If you are stow
Seating and Safety Restraints 62Seating 62Safety restraints 68Airbags 82Child restraints 94Tires, Wheels and Loading 111Tire information 113Tire infla
3. AM/FM: Press to choose afrequency band in radio mode.4. Memory preset buttons: To seta station: Select frequency bandAM/FM1/FM2; tune to a station,
WHEEL LUG NUT TORQUE SPECIFICATIONSRetighten the lug nuts to the specified torque within 100 miles (160 km)after any wheel disturbance (rotation, flat
JUMP STARTINGWARNING: The gases around the battery can explode ifexposed to flames, sparks, or lit cigarettes. An explosion couldresult in injury or v
Connecting the jumper cablesNote: In the illustration, the vehicle on the bottom is used to designatethe assisting (boosting) battery.1. Connect the p
Removing the jumper cablesRemove the jumper cables in the reverse order that they wereconnected.Note: In the illustration, the vehicle on the bottom i
WRECKER TOWINGIf you need to have your vehicle towed, contact a professional towingservice or, if you are a member of a roadside assistance program, y
If the vehicle is towed by other means or incorrectly, vehicledamage may occur.Ford Motor Company produces a towing manual for all authorized towtruck
GETTING THE SERVICES YOU NEEDWarranty repairs to your vehicle must be performed by an authorizedFord, Lincoln, or Mercury dealer. While any authorized
In Canada:Mailing address (Ford vehicles)Customer Relationship CentreFord Motor Company of Canada, LimitedP.O. Box 2000Oakville, Ontario L6J 5E4Teleph
In the United States, a warranty dispute must be submitted to the BBBAUTO LINE before taking action under the Magnuson-Moss WarrantyAct, or to the ext
LINE before exercising rights or seeking remedies created by the FederalMagnuson-Moss Warranty Act, 15 U.S.C. sec. 2301 et seq. If you chooseto seek r
AM/FM stereo single CD/MP3 satellite compatible system(if equipped)WARNING: Driving while distracted can result in loss of vehiclecontrol, accident an
BBB AUTO LINE applications can also be requested by calling the FordMotor Company Customer Relationship Center at 1-800-392-3673.Note: Ford Motor Comp
The use of leaded fuel in your vehicle without proper conversion maydamage the effectiveness of your emission control system and may causeengine knock
If you buy your vehicle in North America and then relocate to any of theabove locations, register your vehicle identification number (VIN) andnew addr
REPORTING SAFETY DEFECTS (U.S. ONLY)If you believe that your vehicle hasa defect which could cause a crashor could cause injury or death, youshould im
WASHING THE EXTERIORWash your vehicle regularly with cool or lukewarm water and a neutralpH shampoo, such as Motorcraft威 Detail Wash (ZC-3-A), which i
WAXING• Wash the vehicle first.• Use a quality wax that does not contain abrasives.• Do not allow paint sealant to come in contact with any non-body(l
ENGINEEngines are more efficient when they are clean because grease and dirtbuildup keep the engine warmer than normal. When washing:• Take care when
4.0L V6 ENGINEPLASTIC (NON-PAINTED) EXTERIOR PARTSUse only approved products to clean plastic parts. These products areavailable from your authorized
• Do not use abrasives, as they may cause scratches.• Do not use fuel, kerosene, or paint thinner to clean any parts.If you cannot remove those streak
3. If necessary, apply more soap and water solution or cleaning productto a clean, white, cotton cloth and press the cloth onto the soiledarea–allow t
3. MUTE: Press to mute the playingmedia. Press again to return to theplaying media.4. MENU: Press MENU repeatedlyto scroll through the followingmodes
• Do not use household cleaning products, alcohol solutions, solvents orcleaners intended for rubber, vinyl and plastics, or oil/petroleum-basedleathe
• Clean the surfaces using the steps outlined in the Cleaning section.• Ensure the leather is dry then apply a nickel-sized amount ofconditioner to a
SERVICE RECOMMENDATIONSTo help you service your vehicle, we provide scheduled maintenanceinformation which makes tracking routine service easy.If your
Working with the engine on1. For vehicles equipped with an automatic transmission, set the parkingbrake and shift to P (Park). For vehicles equipped w
IDENTIFYING COMPONENTS IN THE ENGINE COMPARTMENT2.3L I4 engine1. Windshield washer fluid reservoir2. Engine coolant reservoir3. Engine oil dipstick4.
4.0L V6 engine1. Windshield washer fluid reservoir2. Transmission fluid dipstick (automatic transmission)3. Engine oil filler cap4. Engine oil dipstic
WINDSHIELD WASHER FLUID• 2.3L engine• 4.0L engineAdd fluid to fill the reservoir if the level is low. In very cold weather, donot fill the reservoir c
State or local regulations on volatile organic compounds may restrict theuse of methanol, a common windshield washer antifreeze additive.Washer fluids
1. Make sure the vehicle is on level ground.2. Turn the engine off and wait 15 minutes for the oil to drain into theoil pan.3. Set the parking brake a
• If the oil level is below the lower hole or the MIN mark, add enoughoil to raise the level between the two holes or between the MIN-MAXrange.• Oil l
would like to delete, press SEEK or preset #6. The song willappear in the display for confirmation. Press SEEKor preset #6again and the display will r
economy requirements of the International Lubricant Standardization andApproval Committee (ILSAC), comprised of U.S. and Japaneseautomobile manufactur
To protect your engine and engine’s warranty, use Motorcraft威 SAE5W-30 or an equivalent SAE 5W-30 oil meeting Ford specificationWSS-M2C929-A.Do not us
It is recommended that the negative battery cable terminal bedisconnected from the battery if you plan to store your vehicle for anextended period of
3. Run the engine until it reaches normal operating temperature.4. Allow the engine to idle for at least one minute.5. Turn the A/C on and allow the e
Your vehicle was factory-filled with a 50/50 engine coolant and waterconcentration. If the concentration of coolant falls below 40% or above60%, the e
• 4.0L engineWhen the engine is cold, check the level of the engine coolant in thereservoir.• The engine coolant should be at the FULL COLD level or w
WARNING: Do not add engine coolant when the engine is hot.Steam and scalding liquids released from a hot cooling systemcan burn you badly. Also, you c
WARNING: To reduce the risk of personal injury, make sure theengine is cool before unscrewing the coolant pressure relief cap.The cooling system is un
Recycled engine coolantFord Motor Company does NOT recommend the use of recycled enginecoolant since a Ford-approved recycling process is not yet avai
Vehicles driven year-round in non-extreme climates should use a 50/50mixture of engine coolant and distilled water for optimum cooling systemand engin
Flat file/directory mode: In MP3 mode, use MENU to selectflat file mode or directory mode.Normal / Track title / File name: Use/ to scroll through MP3
Observe the following guidelines when handling automotive fuel:• Extinguish all smoking materialsand any open flames beforerefueling your vehicle.• Al
RefuelingWARNING: Fuel vapor burns violently and a fuel fire can causesevere injuries. To help avoid injuries to you and others:• Read and follow all
light may not reset immediately; it may take several driving cycles forthe check fuel cap lightto turn off. A driving cycle consists of anengine start
Note: Use of any fuel other than those recommended may causepowertrain damage, a loss of vehicle performance, and repairs may notbe covered under warr
Running out of fuelAvoid running out of fuel because this situation may have an adverseeffect on powertrain components.If you have run out of fuel:• Y
able to refuel the full amount of the advertised capacity of thefuel tank due to the empty reserve still present in the tank.For consistent results wh
Habits• Smooth, moderate operation can yield up to 10% savings in fuel.• Steady speeds without stopping will usually give the best fueleconomy.• Idlin
• Adding certain accessories to your vehicle (for example bugdeflectors, rollbars/light bars, running boards, ski/luggage racks) mayreduce fuel econom
Illumination of the service engine soon indicator, charging systemwarning light or the temperature warning light, fluid leaks, strange odors,smoke or
electrical system dry out. After three driving cycles without these or anyother temporary malfunctions present, the service engine soonindicator shoul
11. SEEK/TRACK: Press to accessthe previous/next (/ ) strongstation. In CD/MP3 mode, press toadvance to the previous/next(/ ) track.In satellite radio
Allow the vehicle to sit for at least eight hours without starting theengine. Then, start the engine and complete the above driving cycle. Theengine m
5. If the fluid is low, add fluid in small amounts, until it reaches betweenthe MIN and MAX lines. Refer to Maintenance product specificationsand capa
TRANSMISSION FLUIDChecking automatic transmission fluid• Refer to scheduled maintenance information for scheduled checkand change intervals.• Transmis
Low fluid levelDo not drive the vehicle if the fluidlevel is at or below the bottom ofthe dipstick.High fluid levelFluid levels above the safe rangema
3. Fluid level should be at thebottom of the opening.4. Add enough fluid through thefiller opening so that the fluid levelis at the bottom of the open
DRIVELINE UNIVERSAL JOINT AND SLIP YOKEYour vehicle is equipped with universal joints that do not requirelubrication. If the original universal joints
6. Install a new air filter element. Becareful not to crimp the filterelement edges between the air filterhousing and cover. This could causefilter da
• Lubricate all hood, door and trunk lid hinges, and latches with a lightgrade oil. See the Cleaning chapter for more information.• Cover interior tri
Brakes• Make sure brakes and parking brake are fully released.Tires• Maintain recommended air pressure.Miscellaneous• Make sure all linkages, cables,
MOTORCRAFT PART NUMBERSComponent 2.3L I4 Engine 4.0L V6 EngineAir filter element FA-1744 FA-1744Fuel filter FG-1036 FG-1036Battery BXT-59 BXT-59Oil fi
15. ON/OFF/Volume: Press to turnon/off. Turn to increase/decreasevolume.If the volume is set above a certainlevel and the ignition is turned off,the v
MAINTENANCE PRODUCT SPECIFICATIONS AND CAPACITIESItem CapacityFord Part Name orEquivalentFord Part Number /Ford SpecificationBrake fluid and (clutchfl
Item CapacityFord Part Name orEquivalentFord Part Number /Ford SpecificationEngine coolant (2.3Lengine with manualtransmission)10.5 quarts(10.0L)Motor
Item CapacityFord Part Name orEquivalentFord Part Number /Ford SpecificationAutomatic transmissionfluid (4X2 vehicles with2.3L engine)9.9 quarts(9.4L)
Item CapacityFord Part Name orEquivalentFord Part Number /Ford SpecificationFront axle fluid (4X4)3.6 pints(1.7L)Motorcraft威 SAE 80W-90Premium Rear Ax
Item CapacityFord Part Name orEquivalentFord Part Number /Ford SpecificationFuel tank–regular cab(long wheel base)20.3 gallons(76.8L)——Fuel tank–Super
ENGINE DATAEngine 2.3L I4 engine 4.0L V6 engineCubic inches 138 245Required fuel 87 octane 87 octaneFiring order 1-3-4-2 1-4-2-5-3-6Ignition system ED
• 4.0L V6 engine with A/C• 4.0L V6 engine without A/CMaintenance and Specifications2662011 Ranger (ran)Owners Guide, 1st PrintingUSA (fus)
IDENTIFYING YOUR VEHICLESafety Compliance Certification LabelThe National Highway Traffic SafetyAdministration Regulations requirethat a Safety Compli
The Vehicle Identification Number (VIN) contains the followinginformation:1. World manufacturer identifier2. Brake system / Gross VehicleWeight Rating
FORD CUSTOM ACCESSORIES FOR YOUR VEHICLEA wide selection of Ford Custom Accessories are available for yourvehicle through your local Ford or Ford of C
Required equipment:1. Any portable music player designed to be used with headphones2. An audio extension cable with stereo male 1/8 in. (3.5 mm)connec
Peace of mind•Keyless entry keypad •Seat covers*•Remote start •Windshield wiper shaker*•Vehicle security systems •Back up camera*•Wheel locks •Back up
FORD ESP EXTENDED SERVICE PLANS (U.S. ONLY)More than 30 million Ford, Lincoln, and Mercury owners have discoveredthe powerful protection of Ford ESP.
Ford ESP Can Quickly Pay for ItselfOne service bill – the cost of parts and labor – can easily exceed theprice of your Ford ESP Service Contract. With
Ford Extended Service Plan2732011 Ranger (ran)Owners Guide, 1st PrintingUSA (fus)
FORD ESP EXTENDED SERVICE PLANS (CANADA ONLY)You can get more protection for your vehicle by purchasing a FordExtended Service Plan (ESP). Ford ESP is
GENERAL MAINTENANCE INFORMATIONWhy maintain your vehicle?This guide describes the scheduled maintenance required for yourvehicle. Carefully following
Ford strongly recommends the use of genuine Ford replacement parts.Parts other than Ford, Motorcraft威 or Ford-authorized remanufacturedparts that are
Factory-trained techniciansFord and Lincoln Mercury service technicians participate in extensivefactory-sponsored certification training to help them
Multi-point inspectionIn order to keep your vehicle running right, it is important to have thesystems on your vehicle checked regularly. This can help
Be sure to ask your Ford or Lincoln Mercury dealership service advisoror technician about the multi-point vehicle inspection. It’s acomprehensive way
5. For safety reasons, connecting or adjusting the settings on yourportable music player should not be attempted while the vehicle ismoving. Also, the
Scheduled Maintenance Guide2802011 Ranger (ran)Owners Guide, 1st PrintingUSA (fus)
NORMAL SCHEDULED MAINTENANCE AND LOGThe following section contains the “Normal Schedule”. This schedule ispresented at specific mileage (kilometer) in
Miles (x 1,000)* 7.5 15 22.5 30 37.5 45 52.5 60 67.5 75Kilometers (x 1,000)* 12 24 36 48 60 72 84 96 108 120Months* 6 12 18 24 30 36 42 48 54 60Change
Miles (x 1,000)* 82.5 90 97.5 105 112.5 120 127.5 135 142.5 150Kilometers (x 1,000)* 132 144 156 168 180 192 204 216 228 240Months* 66 72 78 84 90 96
Every 15,000 miles(24,000 km)Replace cabin air filter (if equipped)Every 30,000 miles(48,000 km)Replace climate-controlled seat filter(if equipped)Rep
Maintenance schedule logDEALER VALIDATION:P&A CODE:RO#: HOURS:DATE:MILEAGE:DEALER VALIDATION:P&A CODE:RO#: HOURS:DATE:MILEAGE:DEALER VALIDATIO
DEALER VALIDATION:P&A CODE:RO#: HOURS:DATE:MILEAGE:DEALER VALIDATION:P&A CODE:RO#: HOURS:DATE:MILEAGE:DEALER VALIDATION:P&A CODE:RO#: HOUR
DEALER VALIDATION:P&A CODE:RO#: HOURS:DATE:MILEAGE:DEALER VALIDATION:P&A CODE:RO#: HOURS:DATE:MILEAGE:DEALER VALIDATION:P&A CODE:RO#: HOUR
SPECIAL OPERATING CONDITIONSIf you operate your Ford/Lincoln/Mercury vehicle primarily in one of themore demanding Special Operating Conditions listed
Extensive idling and/or low-speed driving for long distances as in heavycommercial use such as delivery, taxi, patrol car or liveryInspect frequently,
• Wipe discs from the center out.Don’t:• Expose discs to direct sunlight or heat sources for extended periodsof time.• Clean using a circular motion.C
Operating in dusty conditions such as unpaved or dusty roadsInspect frequently, service asrequired– Replace cabin air filter (if equipped).– Replace e
Off-road operationInspect frequently, service asrequired– Replace cabin air filter (if equipped).– Replace engine air filter.– Inspect and lubricate s
Special operating condition logDEALER VALIDATION:P&A CODE:RO#: HOURS:DATE:MILEAGE:DEALER VALIDATION:P&A CODE:RO#: HOURS:DATE:MILEAGE:DEALER VA
DEALER VALIDATION:P&A CODE:RO#: HOURS:DATE:MILEAGE:DEALER VALIDATION:P&A CODE:RO#: HOURS:DATE:MILEAGE:DEALER VALIDATION:P&A CODE:RO#: HOUR
EXCEPTIONSIn addition, there are several exceptions to the Normal Schedule. Theyare listed below:Normal vehicle axle maintenance❑Rear axles and power
COOLANT CHANGE RECORDHot climate oil change intervals❑If operating conditions are normal and you drive your Ford, Lincoln or Mercury vehicle under typ
Engine coolant change logDEALER VALIDATION:P&A CODE:RO#: HOURS:DATE:MILEAGE:DEALER VALIDATION:P&A CODE:RO#: HOURS:DATE:MILEAGE:DEALER VALIDATI
AABS (see Brakes) ...155AdvanceTrac ...158Air cleaner filter ...255–256, 259Airbag supplemental restr
wheels ...215wiper blades ...217Clock adjustAM/FM ...2
indicator light ...171preparing to drive yourvehicle ...164Fuel ...
Maintenance and Specifications 222Engine compartment 224Engine oil 227Battery 231Engine coolant 233Fuel information 239Air filter(s) 255Part numbers 2
Operating your audio system with MP3-formatted discsYour MP3 system recognizes MP3 discs upon insertion and provides youwith two ways to listen to the
replacing bulbs ...44LATCH anchors ...102Lights, warning and indicator ...12anti-lock brakes (ABS) ...
extension assembly ...77for adults ...72, 74, 76for children ...94lap belt ...
manual operation ...168Turn signal ...42VVehicle Identification Number(VIN) ...
• MP3 flat file mode ignores any folder structure on the MP3 disc. Theplayer numbers each MP3 track on the disc (noted by the .mp3 fileextension) from
Satellite radio information (if equipped)Satellite radio channels: SIRIUS威 broadcasts a variety of music, news,sports, weather, traffic and entertainm
Satellite radio electronic serial number (ESN): This 12–digitSatellite Serial Number is needed to activate, modify or track yoursatellite radio accoun
Radio Display Condition Action RequiredNO TEXT Song title informationnot available.Song title information notavailable at this time onthis channel. Th
HEATER ONLY SYSTEM(IF EQUIPPED)1. Fan speed adjustment: Controlsthe volume of air circulated in thevehicle.2. Temperature selection:Controls the tempe
To aid in side window defogging/demisting in cold weather:1. Select .2. Adjust the temperature control to maintain comfort.3. Set the fan speed to the
Operating tips• To reduce fog build-up on the windshield during humid weather, placethe air flow selector in theposition.• To reduce humidity build-up
HEADLAMP CONTROLTurns the lamps off.Turns on the parking lamps,instrument panel lamps, licenseplate lamps and tail lamps.Turns the low beam headlampso
Flash-to-passPull toward you slightly to activateand release to deactivate.Daytime running lamps (DRL) (if equipped)The daytime running light system t
CONGRATULATIONSCongratulations on acquiring your new Ford. Please take the time to getwell acquainted with your vehicle by reading this handbook. The
Note: If the battery is disconnected, discharged, or a new battery isinstalled, the dimmer switch requires re-calibration. Rotate the dimmerswitch fro
3. Turn on the low beam headlampsand open the hood.4. Locate the high intensity area ofthe beam pattern and place the topedge of the intensity zone ev
TURN SIGNAL CONTROL• Push down to activate the leftturn signal.• Push up to activate the right turnsignal.INTERIOR LAMPSCourtesy/reading lamps (if equ
Examples of unacceptable moisture (usually caused by a lamp waterleak) are:• Water puddle inside the lamp• Large water droplets, drip marks or streaks
Replacing headlamp bulbs/front park bulbs/turn signal bulbsTo remove the bulb(s):1. Make sure the headlamp switch isin the off position, then open the
Replacing front sidemarker bulbs1. Turn the headlamp switch to theoff position, then open the hood.2. At the back of the headlamp, pryup the two retai
Replacing tail lamp/backup lamp bulbs1. Make sure the headlamp switch isin the off position, then open thetailgate to expose the lampassemblies.2. Rem
Replacing fog lamp bulbs (if equipped)1. Make sure the headlamp switch isin the off position and remove thebulb socket from the fog lamp byturning it
MULTI-FUNCTION LEVERWindshield wiper: Rotate the endof the control away from you toincrease the speed of the wipers(from desired interval to low or hi
TILT STEERING WHEEL (IF EQUIPPED)To adjust the steering wheel:1. Pull and hold the steering wheelrelease control toward you.2. Move the steering wheel
Warning symbols on your vehicleWhen you see this symbol, it isimperative that you consult therelevant section of this guide beforetouching or attempti
AUXILIARY POWER POINT (12V DC)Power outlets are designed for accessory plugs only. Do not insertany other object in the power outlet as this will dama
Press and pull the window switchesto open and close windows.• Press down (to the first detent)and hold the switch to open.• Pull up and hold the switc
Fold-away mirrorsPull the side mirrors in carefullywhen driving through a narrowspace, like an automatic car wash.SPEED CONTROL (IF EQUIPPED)With spee
Note:• Vehicle speed may vary momentarily when driving up and down asteep hill.• If the vehicle speed increases above the set speed on a downhill, you
POSITIVE RETENTION FLOOR MAT (IF EQUIPPED)WARNING: Do not install additional floor mats on top of thefactory installed floor mats as they may interfer
KEYSThe key operates all locks on your vehicle. You should always carry asecond key with you in a safe place in case you require it in anemergency.If
Your vehicle is equipped with a remote entry system which allows you to:• unlock the vehicle doors withouta key.• lock all the vehicle doors withouta
Note: The panic alarm will only operate when the ignition is in the offposition.Replacing the batteryThe remote entry transmitter uses one coin type t
How to reprogram your remote entry transmittersYou must have all remote entry transmitters (maximum of four)available before beginning this procedure.
The inside lights will not turn off if:• they have been turned on with the dimmer control, or• any door is open.The battery saver will shut off the in
Do not add friction modifier compounds or special break-in oils sincethese additives may prevent piston ring seating. See Engine oil in theMaintenance
Anti-theft indicatorThe anti-theft indicator is located in the instrument cluster.Vehicles equipped with theSecuriLock威 passive anti-theftsystem behav
1. Insert a previously programmedcoded key into the ignition.2. Turn the ignition from the 2(lock) position to the 4 (on)position. Keep the ignition i
FRONT SEATINGWARNING: Reclining the seatback can cause an occupant toslide under the seat’s safety belt, resulting in severe personalinjuries in the e
To adjust the head restraint, do the following:1. Adjust the seatback to an upright driving/riding position.2. Raise the head restraint bypulling up o
To remove the adjustable head restraint, do the following:1. Pull up the head restraint until itreaches the highest adjustmentposition.2. Simultaneous
WARNING: To minimize the risk of neck injury in the event of acrash, head restraints must be installed properly.Adjusting the front manual seatWARNING
Lift the release bar to move seatforward or backward. Ensure thatthe seat is locked into place.Pull lever located at the side of theseat cushion up to
Passenger side rear accessPull up on the recliner handle. Theseat will lean forward. Lift therelease bar to move the seat forwardto access the rear ar
WARNING: Booster seats must be installed only in seatingpositions equipped with a combination lap/shoulder belt.SAFETY RESTRAINTSPersonal Safety Syste
the system. Rather, it means the Personal Safety System determined theaccident conditions (crash severity, belt usage, etc.) were notappropriate to ac
Using your vehicle as an ambulanceDo not use this vehicle as an ambulance.Your vehicle is not equipped with the Ford Ambulance PreparationPackage.DATA
WARNING: Airbags can kill or injure a child in a child seat.NEVER place a rear-facing child seat in front of an active airbag.If you must use a forwar
Determining if the Personal Safety System is operationalThe Personal Safety System uses a warning light in the instrumentcluster or a back-up tone to
WARNING: It is extremely dangerous to ride in a cargo area,inside or outside of a vehicle. In a collision, people riding inthese areas are more likely
2. To unfasten, press the releasebutton and remove the tongue fromthe buckle.Restraint of pregnant womenWARNING: Always ride and drive with your seatb
Insert the tongue into the correctbuckle (the buckle closest to thedirection the tongue is comingfrom). To lengthen the belt, turn thetongue at a righ
When to use the automatic locking modeThis mode should be used any time a child safety seat, except abooster, is installed in passenger front or rear
WARNING: After any vehicle collision, the safety belt system atall passenger seating positions must be checked by an authorizeddealer to verify that t
Safety belt extension assemblyIf the safety belt is too short when fully extended, there is an 8 inch(20 cm) safety belt extension assembly that can b
WARNING: Position the safety belt height adjusters so that thebelt rests across the middle of your shoulder. Failure to adjustthe safety belt properly
Both the driver’s and passenger’s safety belt usages are monitored andeither may activate the Belt-Minder威 feature. The warnings are the samefor the d
Note: EDR data is recorded by your vehicle only if a non-trivialcrash situation occurs; no data is recorded by the EDR undernormal driving conditions
The following are reasons most often given for not wearing safety belts(All statistics based on U.S. data):Reasons given... Consider...“Crashes are ra
WARNING: Do not sit on top of a buckled safety belt or insert alatchplate into the buckle to avoid the Belt-Minder威 chime. Todo so may adversely affec
1. Turn the ignition switch to the on position. DO NOT START THEENGINE.2. Wait until the safety belt warning light turns off (Approximately oneminute)
safety belts in impacts for which the airbags are designed to deploy, andairbags do not offer any protection in crashes for which they do notdeploy.Th
WARNING: National Highway Traffic Safety Administration(NHTSA) recommends a minimum distance of at least 25 cm(10 inches) between an occupant’s chest
Children and airbagsFor additional important safety information, read all information onsafety restraints in this guide.WARNING: Do not install achild
WARNING: Booster seats must be installed only in seatingpositions equipped with a combination lap/shoulder belt.WARNING: To reduce the risk of injury,
restrained or are otherwise out of position at the time of airbagdeployment. Thus, it is extremely important that occupants be properlyrestrained as f
WARNING: Even with Advanced Restraints Systems, children12 and under should be properly restrained in a rear seatingposition (if equipped).When the fr
OccupantPass Airbag OffIndicator LampPassenger AirbagEmpty seat Unlit DisabledSmall child in childsafety seat or boosterLit DisabledSmall child with s
Ford or its vendors to receive this information, do not activatethe service. Ford Motor Company and the vendors it uses toprovide you with this inform
The front passenger sensing system may detect small or medium objectsplaced on the seat cushion. For most objects that are in the frontpassenger seat,
Seat-mounted side airbag systemWARNING: Do not place objects or mount equipment on ornear the airbag cover on the side of the seatbacks of the frontse
The side airbag system consists of the following:• An inflatable bag (airbag) with a gas generator concealed behind theoutboard bolster of the driver
Determining if the system is operationalThe SRS uses a readiness light in the instrument cluster or a tone toindicate the condition of the system. Ref
SAFETY RESTRAINTS FOR CHILDRENSee the following sections for directions on how to properly use safetyrestraints for children. Also see Airbag suppleme
Recommendations for Safety Restraints for ChildrenChild size, height, weight, or ageRecommendedrestraint typeInfants ortoddlersChildren weighing 40 lb
Recommendations for attaching child safety restraints for childrenRestraintTypeChildWeightUse any attachment method as indicatedbelow by “X”LATCH(lowe
WARNING: Never let a passenger hold a child on his or her lapwhile the vehicle is moving. The passenger cannot protect thechild from injury in a colli
Follow all the safety restraint and airbag precautions that apply to adultpassengers in your vehicle.If the child is the proper height, age, and weigh
position whenever possible. If all children cannot be seated andrestrained properly in a rear seating position, properly restrain thelargest child in
Commentaires sur ces manuels