Ford 2011 E-450 v.1 Manuel d'utilisateur

Introduction 4Instrument Cluster 14Warning lights and chimes 14Gauges 19Message center 21Entertainment Systems 29AM/FM stereo 29AM/FM stereo with CD 3

CELL PHONE USEThe use of Mobile Communications Equipment has become increasinglyimportant in the conduct of business and personal affairs. However,dri

If... Then...The driver’s safety belt is notbuckled approximately5 seconds after the safety beltwarning light has turned off...The Belt-Minder威 featur

Reasons given... Consider...“I was in a hurry” Prime time for an accident.Belt-Minder威 reminds us to take a fewseconds to buckle up.“Safety belts don’

Deactivating/activating the Belt-Minder姞 featureRead Steps1-5thoroughly before proceeding with thedeactivation/activation programming procedure.The Be

• This will enable the Belt-Minder威 feature for that seating position if itis currently disabled. As confirmation, the safety belt warning light willf

Important SRS precautionsThe SRS is designed to work withthe safety belt to help protect thedriver and right front passengerfrom certain upper body in

WARNING: Do not put anything on or over the air bag module.Placing objects on or over the air bag inflation area may causethose objects to be propelle

How does the airbag supplemental restraint system work?The airbag SRS is designed toactivate when the vehicle sustains alongitudinal deceleration suff

• safety belt pretensioners• a readiness light and tone• a diagnostic module• and the electrical wiring which connects the componentsThe diagnostic mo

The system can be turned off when any one of the following actions aretaken by the driver or any other person:• pressing the hazard control button,• o

Turning the passenger airbag off1. Insert the ignition key, turn theswitch to OFF position and hold inOFF position while removing thekey.2. When the i

EXPORT UNIQUE (NON–UNITED STATES/CANADA) VEHICLESPECIFIC INFORMATIONFor your particular global region, your vehicle may be equipped withfeatures and o

WARNING: If the OFF light is illuminated when the passengerairbag switch is in the ON position and the ignition switch is inON, have the passenger air

Read all airbag warning labels in the vehicle as well as the otherimportant airbag instructions and warnings in this Owner’s Guide.NHTSA deactivation

Transport Canada deactivation criteria (Canada Only)1. Infant: An infant (less than 1 year old) must ride in the front seatbecause:• my vehicle has no

SAFETY RESTRAINTS FOR CHILDRENSee the following sections for directions on how to properly use safetyrestraints for children. Also see Airbag suppleme

Recommendations for Safety Restraints for ChildrenChild size, height, weight, or ageRecommendedrestraint typeInfants ortoddlersChildren weighing 40 lb

• When possible, always properly restrain children twelve (12) years ofage and under in a rear seating position of your vehicle. Accidentstatistics su

WARNING: Always carefully follow the instructions andwarnings provided by the manufacturer of any child restraint todetermine if the restraint device

training to ensure that all children ages 0 to 16 are properly restrained inthe correct restraint system. Ford recommends checking with a NHTSACertifi

Airbags can kill or injure a child in a child seat. NEVER place arear-facing child seat in front of an active airbag. If you must use aforward-facing

1. Position the child safety seat in aseat with a combination lap andshoulder belt.2. Pull down on the shoulder beltand then grasp the shoulder beltan

These are some of the symbols you may see on your vehicle.Vehicle Symbol GlossarySafety AlertSee Owner’s GuideFasten Safety Belt Airbag - FrontAirbag

4. Insert the belt tongue into theproper buckle (the buckle closest tothe direction the tongue is comingfrom) for that seating position untilyou hear

towards the buckle will additionally help to remove remaining slack fromthe belt.9. Attach the tether strap (if thechild seat is equipped). Refer toAt

Your vehicle has LATCH lower and/or top tether anchors at thefollowing locations:• Five passenger crew van• Seven passenger wagon• Eight passenger wag

• Eleven passenger wagon• Twelve passenger wagon• Fifteen passenger wagonSeating and Safety Restraints1232011 Econoline (eco)Owners Guide, 1st Printin

The LATCH lower anchors arelocated at the rear section of therear seat between the cushion andseatback. Follow the child seatmanufacturer’s instructio

Attaching child safety seats with tether strapsWARNING: When using forward-facing child safety seats invehicles with only two seating positions or the

Perform the following steps to install a child safety seat with tetheranchors:Front passenger seating positionThe tether can be attached directlyto th

2. Route the child safety seat tetherstrap over the back of the frontright-hand passenger seat as shown.3. Clip the tether strap hook to theseat pedes

4. Adjust the front right handpassenger seat to the full rearwardposition.5. Tighten the child safety seattether strap according to themanufacturer’s

2. Clip the tether strap hook to theseat pedestal at the location shown.If the tether strap is clippedincorrectly, the child safety seat maynot be ret

Vehicle Symbol GlossaryPower WindowsFront/RearPower Window LockoutChild Safety DoorLock/UnlockInterior LuggageCompartment ReleasePanic Alarm Engine Oi

2. Route the child safety tetherstrap over the back of the benchseat.3. For any three passenger bench,clip the center tether strap hook tothe tether b

Booster seats position a child so that vehicle lap/shoulder safety belts fitbetter. They lift the child up so that the lap belt rests low across the h

Types of booster seatsThere are generally two types of belt-positioning booster seats: backlessand high back. Always use booster seats in conjunction

Children and booster seats vary in size and shape. Choose a booster thatkeeps the lap belt low and snug across the hips, never up across thestomach, a

Follow all instructions provided by the manufacturer of the booster seat.WARNING: Never place, or allow a child to place, the shoulderbelt under a chi

NOTICE TO UTILITY VEHICLE AND TRUCK OWNERSUtility vehicles and trucks handledifferently than passenger cars inthe various driving conditions thatare e

VEHICLE CHARACTERISTICSHow your vehicle differs from other vehiclesSUVs and trucks can differ fromsome other vehicles in a fewnoticeable ways. Your ve

INFORMATION ABOUT UNIFORM TIRE QUALITY GRADINGTire Quality Grades apply to newpneumatic passenger car tires. TheQuality grades can be found whereappli

WARNING: The traction grade assigned to this tire is based onstraight-ahead braking traction tests, and does not includeacceleration, cornering, hydro

• Recommended inflation pressure: The cold inflation pressure foundon the Safety Compliance Certification Label or Tire Label located onthe B-Pillar o

WARNING LIGHTS AND CHIMESWarning lights and gauges can alert you to a vehicle condition that maybecome serious enough to cause expensive repairs. A wa

Always inflate your tires to the Ford recommended inflation pressureeven if it is less than the maximum inflation pressure information foundon the tir

5. Repeat this procedure for each tire, including the spare.Note: Some spare tires operate at a higher inflation pressure than theother tires. For T-t

Tire inflation informationAll tires with Steel Carcass Plies (if equipped):This type of tire utilizes steel cords in the sidewalls. As such, theycanno

WARNING: Stay out of the trajectory (1) as indicated in theillustration.TIRE CAREInspecting your tires and wheel valve stemsPeriodically inspect the t

Improper or inadequate vehicle maintenance can cause tires to wearabnormally. Inspect all your tires, including the spare, frequently, andreplace them

U.S. DOT Tire Identification Number (TIN)Both U.S. and Canada Federal regulations require tire manufacturers toplace standardized information on the s

WARNING: When mounting replacement tires and wheels, youshould not exceed the maximum pressure indicated on thesidewall of the tire to set the beads w

• Do not run over curbs or hit the tire against a curb when parkingWARNING: If your vehicle is stuck in snow, mud, sand, etc., donot rapidly spin the

• Rear-wheel drive (RWD)vehicles/Four-wheel drive(4WD)/All-wheel drive (AWD)vehicles (front tires at top ofdiagram)Sometimes irregular tire wear can b

• DRW – Six tire rotationIf your vehicle is equipped with dualrear wheels it is recommended thatthe front and rear tires (in pairs) berotated only sid

light will stay on until the engine is cranked, then turn itself off if nomalfunctions are present. However, if after 15 seconds the service enginesoo

Information on “P” type tiresP215/65R15 95H is an example of atire size, load index and speedrating. The definitions of theseitems are listed below. (

Note: You may not find this information on all tires because it is notrequired by federal law.Letter rating Speed rating - mph (km/h)M 81 mph (130 km/

12. Treadwear, Traction and Temperature Grades• Treadwear: The treadwear grade is a comparative rating based on thewear rate of the tire when tested u

Additional information contained on the tire sidewall for “LT” typetires“LT” type tires have some additionalinformation beyond those of “P”type tires;

Information on “T” type tires“T” type tires have some additionalinformation beyond those of “P”type tires; these differences aredescribed below:T145/8

TIRE PRESSURE MONITORING SYSTEM (TPMS) (IF EQUIPPED)Each tire, including the spare (ifprovided), should be checkedmonthly when cold and inflated tothe

The tire pressure monitoring system complies with part 15 of the FCCrules and with RSS-210 of Industry Canada. Operation is subject to thefollowing tw

To restore the full functionality of the tire pressure monitoring system,have the damaged road wheel/tire repaired and remounted on yourvehicle. For a

Low tirepressurewarning lightPossiblecauseCustomer action requiredSolid warning light Tire(s)under-inflated1. Check your tire pressure toensure tires

Low tirepressurewarning lightPossiblecauseCustomer action requiredFlashing warninglightSpare tire inuseYour temporary spare tire is inuse. Repair the

WARNING: Driving a vehicle with the brake system warninglight on is dangerous. A significant decrease in brakingperformance may occur. It will take yo

under-inflated, carefully drive the vehicle to the nearest location whereair can be added to the tires. Inflate all the tires to the recommendedinflat

2. Place the ignition in the off position and keep the key in the ignition.3. Cycle the ignition to the onposition with the engine off.4. Turn the haz

8. Remove the valve cap from the valve stem on the right rear tire.Decrease the air pressure until the horn sounds.9. Remove the valve cap from the va

• Install chains securely, verifying that the chains do not touch anywiring, brake lines or fuel lines.• Drive cautiously. If you hear the chains rub

Payload – is the combined weight of cargo and passengers that thevehicle is carrying. The maximum payload for your vehicle can be foundon the Tire Lab

Example only:Cargo Weight – includes all weight added to the Base Curb Weight,including cargo and optional equipment. When towing, trailer tongue load

GAWR (Gross Axle Weight Rating) – is the maximum allowableweight that can be carried by a single axle (front or rear). Thesenumbers are shown on the S

• Example only:WARNING: Exceeding the Safety Compliance Certification Labelvehicle weight rating limits could result in substandard vehiclehandling or

GCW (Gross Combined Weight) – is the weight of the loaded vehicle(GVW) plus the weight of the fully loaded trailer.GCWR (Gross Combined Weight Rating)

WARNING: Exceeding any vehicle weight rating limitation couldresult in serious damage to the vehicle and/or personal injury.Steps for determining the

Low tire pressure warning (ifequipped): Illuminates when yourtire pressure is low. If the lightremains on at start up or whiledriving, the tire pressu

x 100) = 1400 - 440 - 1200 = - 240 lb. No, you do not have enoughcargo capacity to carry that much weight. In metric units, thecalculation would be: 6

Towing a trailer places an additional load on your vehicle’s engine,transmission, axle, brakes, tires and suspension. Inspect thesecomponents carefull

EngineRear axleratioMaximumGCWR - lb (kg)Maximum TrailerWeight - lb (kg)E-350 Regular Wagon (11/12 Passenger)5.4L 3.73/4.10 13000 (5896) 6700 (3039)6.

EngineRear axleratioMaximumGCWR - lb (kg)Maximum TrailerWeight - lb (kg)E-350 Stripped Chassis Single Rear Wheel (SRW) 138” Wheelbase5.4L 3.73/4.10 13

WARNING: Towing trailers beyond the maximum recommendedgross trailer weight exceeds the limit of the vehicle and couldresult in engine damage, transmi

The braking system of the tow vehicle is rated for operation at theGVWR not GCWR.Integrated trailer brake controller (if equipped)Your vehicle may be

• TBC GAIN = XX.X OUTPUT = //////: When the vehicle’s brake pedalis pushed, or when the manual control is activated, bar indicators willilluminate in

2. Hook up the trailer and make the electrical connections according tothe trailer manufacturer’s instructions.3. When a trailer with electric brakes

Points to Remember:• Remember to adjust gain setting before using the TBC for the firsttime.• Readjust GAIN setting on the TBC (according to procedure

• Consider turning overdrive off (4–speed transmissions) or using thetow/haul feature (5–speed transmissions) to eliminate excessiveshifting and assis

Anti-theft system: Flashes whenthe SecuriLock威 Passive Anti-theftSystem has been activated.Overdrive off (if equipped):Illuminates when the overdrivef

When backing down a ramp during boat launching or retrieval:• Do not allow the static water level to rise above the bottom edge ofthe rear bumper.• Do

STARTINGPositions of the ignition1. Accessory — allows the electricalaccessories such as the radio tooperate while the engine is notrunning.2. Lock —

WARNING: Do not start your vehicle in a closed garage or inother enclosed areas. Exhaust fumes can be toxic. Always openthe garage door before you sta

• Turn the key to 4 (on) withoutturning the key to 5 (start).Some warning lights will briefly illuminate. See Warning lights andchimes in the Instrume

You may experience a decrease in peak performance when the engine iscold when operating on E85ethanol.Do not crank the engine for more than 10 seconds

See Cold weather starting earlier in this chapter for more informationon starting with ethanol.WARNING: Failure to follow engine block heater instruct

• Be sure that the engine block heater, heater cord and extension cordare solidly connected. A poor connection can cause the cord tobecome very hot an

Using ABSWhen hard braking is required, apply continuous force on the brakepedal. Do not pump the brake pedal since this will reduce theeffectiveness

The parking brake is not recommended to stop a moving vehicle.However, if the normal brakes fail, the parking brake can be used to stopyour vehicle in

button will not turn the system on or off and your vehicle should beserviced by an authorized dealer.ADVANCETRAC姞 WITH ROLL STABILITY CONTROL™ (RSC姞)S

Parking brake on warning chime: Sounds when the parking brake isset, the engine is running and the vehicle is driven more than 3 mph(5 km/h).GAUGESSpe

WARNING: If a failure has been detected within theAdvanceTrac威 with RSC威 system, the stability control light andTCS OFF light will illuminate steadily

• If the driving condition is severe and your foot is not on the brake, thebrake pedal may move as the systems applies higher brake forces. Youmay als

Certain adverse driving maneuvers may activate the ESC system, whichinclude but are not limited to:• Taking a turn too fast• Maneuvering quickly to av

20 mph (32 km/h) will turn off the stability control light and TCS OFFlight. The switch will not allow partial AdvanceTrac威 with RSC威 systemdisabling

• Heavy or uneven steering efforts may be caused by low power steeringpump fluid level. Check for low power steering pump fluid level beforeseeking se

WARNING: Vehicles with a higher center of gravity such asutility vehicles and trucks handle differently than vehicles with alower center of gravity. U

Emergency maneuvers• In an unavoidable emergency situation where a sudden sharp turnmust be made, remember to avoid “over-driving” your vehicle, i.e.,

If the fuse is not blown and the brake lamps are working properly, thefollowing procedure will allow you to move the gearshift lever from P(Park):1. A

AUTOMATIC TRANSMISSION OPERATIONUnderstanding the gearshift positions of the 4–speed automatictransmissionYour vehicle has been designed to improve fu

WARNING: Always set the parking brake fully and make surethe gearshift is latched in P (Park). Turn the ignition to the lockposition and remove the ke

Seating and Safety Restraints 85Seating 85Safety restraints 93Airbags 103Child restraints 113Tires, Wheels and Loading 135Tire information 137Tire inf

WARNING: Never remove the coolant reservoir cap while theengine is running or hot.Odometer: Registers the total miles(kilometers) of the vehicle.Refer

2 (Second)This position allows for second gear only.• Provides engine braking.• Use to start-up on slippery roads.• To return to(Overdrive), move the

The adaptive transmission shift strategy allows the transmission torelearn these operating parameters. This learning process could takeseveral transmi

To activate tow/haul, press thebutton on the end of the gearshiftlever.The TOW HAUL indicator light willilluminate in the instrument cluster.Tow/haul

• The transmission will not downshift into 1 (First) at high speeds; itwill downshift to a lower gear and then shift into 1 (First) when thevehicle re

WARNING: To help avoid personal injury, please read andunderstand the limitations of the reverse sensing system ascontained in this section. Reverse s

The RSS detects obstacles up to6 feet (2 meters) from the rearbumper with a decreased coveragearea at the outer corners of thebumper, (refer to the fi

REARVIEW CAMERA SYSTEM (IF EQUIPPED)The rearview camera system locatedon the back door provides a videoimage, which appears in therearview mirror or n

Note: The default setting for the rear camera delay is off. Press the“Settings” button found on the navigation screen (if equipped) to set therear cam

Servicing• If the image comes on while the vehicle is not in R (Reverse), havethe system inspected by your authorized dealer.• If the image is not cle

VEHICLE USED AS A STATIONARY POWER SOURCEAuxiliary equipment called power take-off or PTO, is often added to theengine or transmission to operate util

Fuel gauge: Indicatesapproximately how much fuel is leftin the fuel tank (when the ignitionis in the on position). The fuelgauge may vary slightly whe

ROADSIDE ASSISTANCEGetting roadside assistanceTo fully assist you should you have a vehicle concern, Ford MotorCompany offers a complimentary roadside

Canadian customers refer to your Customer Information Guidefor information on:• coverage period• exact fuel amounts• towing of your disabled vehicle•

HAZARD FLASHER CONTROLThe hazard flasher is located on thesteering column, just behind thesteering wheel. The hazard flasherswill operate when the ign

The switch is located on a bracketabove the brake pedal.To reset the switch:1. Turn the ignition off.2. Check the fuel system for leaks.3. If no leaks

FUSES AND RELAYSFusesIf electrical components in thevehicle are not working, a fuse mayhave blown. Blown fuses areidentified by a broken wire withinth

Passenger compartment fuse panelThe fuse panel is located to the left of the brake pedal and mountedonto the lower left cowl panel. Remove the fuse pa

The fuses are coded as follows.Fuse/RelayLocationFuse AmpRatingProtected Circuits1 30A Not used (spare)2 15A Not used (spare)3 15A Not used (spare)4 3

Fuse/RelayLocationFuse AmpRatingProtected Circuits28 5A Audio mute (start)29 5A Cluster (except stripped chassis)30 5A Not used (spare)31 10A Not used

Power distribution boxThe power distribution box is located in the engine compartment. Thepower distribution box contains high-current fuses that prot

Fuse/RelayLocationFuse AmpRatingProtected Circuits4 HC Micro Relay Trailer tow battery charge5 HC Micro Relay Fuel pump6 HC Micro Relay Trailer tow pa

XX.X MPG (L/100km)Average fuel economy displays your average fuel economy in miles/gallonor liters/100 km.If you calculate your average fuel economy b

Fuse/RelayLocationFuse AmpRatingProtected Circuits31 10A* Cluster battery (stripped chassis)32 50A** Blower motor33 40A** Anti-lock brake system (ABS)

Fuse/RelayLocationFuse AmpRatingProtected Circuits59 — Not used60 — One touch integrated start (OTIS)(diode)61 — Auxiliary battery (diode)62 HC Micro

CHANGING THE TIRESIf you get a flat tire while driving, do not apply the brake heavily.Instead, gradually decrease your speed. Hold the steering wheel

A dissimilar spare tire/wheel is defined as a spare tire and/or wheel thatis different in brand, size or appearance from the road tires and wheelsand

The usage of a full-size dissimilar spare tire/wheel can lead toimpairment of the following:• Handling, stability and braking performance• Comfort and

4. Apply the parking brake and turnthe engine off.Spare tire informationThe spare tire for your vehicle is stowed under the rear of your vehicle(excep

Tire change procedureWARNING: To help prevent the vehicle from moving when youchange a tire, be sure the parking brake is set, then block (inboth dire

• The jack is located in the rearright-hand side of the cargo area.3. Remove any wheel trim. Insert the tapered end of the lug nut wrenchbehind wheel

• Never use the front or reardifferential as a jacking point.Rear axle jacking points - Allmodels except E-350 Dual RearWheel (DRW) and E-450:Rear axl

Front axle jacking points:Place the jack under the pin on thefront surface of the front axle.Do not place the jack under oron the steering linkage.3.

To reset the oil monitoring system to 100% after each oil change,perform the following:1. Press and release the SELECT/RESET stem to display “OIL LIFE

WARNING: Never usewheels or lug nuts differentthan the original equipment asthis could damage the wheel ormounting system. This damagecould allow the

5. Repeat this tightness check procedure when servicing the spare tirepressure (every six months, as per your scheduled maintenanceinformation), or at

WARNING: When a wheel is installed, always remove anycorrosion, dirt or foreign materials present on the mountingsurfaces of the wheel or the surface

Preparing your vehicleWhen the battery is disconnected or a new battery is installed, theautomatic transmission must relearn its shift strategy. As a

1. Connect the positive (+) jumpercable to the positive (+) terminal ofthe discharged battery.2. Connect the other end of thepositive (+) cable to the

Removing the jumper cablesRemove the jumper cables in the reverse order that they wereconnected.Note: In the illustration, the vehicle on the bottom i

WRECKER TOWINGIf you need to have your vehicle towed, contact a professional towingservice or, if you are a member of a roadside assistance program, y

Emergency towingIn case of a roadside emergency with a disabled vehicle (without accessto wheel dollies, car hauling trailer, or flatbed transport veh

GETTING THE SERVICES YOU NEEDWarranty repairs to your vehicle must be performed by an authorizedFord, Lincoln, or Mercury dealer. While any authorized

• Service specials and promotions.In Canada:Mailing Address (Ford vehicles)Customer Relationship CentreFord Motor Company of Canada, LimitedP.O. Box 2

Press and hold the SELECT/RESET stem to turn this feature on or off.(You can also choose to turn this feature on/off when the vehicle isplaced in reve

• date of vehicle purchase• current odometer reading• vehicle identification number (VIN)Additional AssistanceIf you have questions or concerns, or ar

California Civil Code Section 1793.22(b) presumes that the manufacturerhas had a reasonable number of attempts to conform the vehicle to itsapplicable

scheduled so that you can present your case in an informal settingbefore an impartial person. The arbitrator will consider the testimonyprovided and m

settlement have failed. This procedure is without cost to you and isdesigned to eliminate the need for lengthy and expensive legalproceedings.In the C

If your vehicle must be serviced while you are traveling or living inPuerto Rico, contact the nearest authorized dealer. If the authorizeddealer canno

(Items in this catalog may be purchased by credit card, check ormoney order.)Obtaining a French Owner’s GuideFrench Owner’s Guides can be obtained fro

WASHING THE EXTERIORWash your vehicle regularly with cool or lukewarm water and a neutralpH shampoo, such as Motorcraft威 Detail Wash (ZC-3-A), which i

WAXING• Wash the vehicle first.• Use a quality wax that does not contain abrasives.• Do not allow paint sealant to come in contact with any non-body(l

ENGINEEngines are more efficient when they are clean because grease and dirtbuildup keep the engine warmer than normal. When washing:• Take care when

WINDOWS AND WIPER BLADESThe windshield, rear and side windows and the wiper blades should becleaned regularly. If the wipers do not wipe properly, sub

6. Release the SELECT/RESET stem and allow the setup timer to expireto exit the procedure.Compass calibration adjustmentNote: For optimum calibration,

• Do not use household or glass cleaners as these may damage thefinish of the instrument panel, interior trim and cluster lens.• Do not allow air fres

WARNING: Do not use cleaning solvents, bleach or dye on thevehicle’s seatbelts, as these actions may weaken the beltwebbing.LEATHER SEATS(IF EQUIPPED,

• Do not spill coffee, ketchup, mustard, orange juice or oil-basedproducts on the leather as they may permanently stain the leather.• Do not use house

FORD AND LINCOLN MERCURY CAR CARE PRODUCTSYour Ford or Lincoln Mercury authorized dealer has many qualityproducts available to clean your vehicle and

SERVICE RECOMMENDATIONSTo help you service your vehicle, we provide scheduled maintenanceinformation which makes tracking routine service easy.If your

OPENING THE HOOD1. Inside the vehicle, pull the hoodrelease handle located under thebottom left corner of the instrumentpanel.2. Go to the front of th

IDENTIFYING COMPONENTS IN THE ENGINE COMPARTMENT1. Battery2. Windshield washer fluid reservoir3. Engine oil filler cap4. Automatic transmission fluid

WINDSHIELD WASHER FLUIDAdd fluid to fill the reservoir if thelevel is low. In very cold weather, donot fill the reservoir completely.Only use a washer

To prolong the life of the wiper blades, it is highly recommended toscrape off the ice on the windshield before turning on the wipers. Thelayer of ice

7. Put the dipstick back in and ensure it is fully seated.Adding engine oil1. Check the engine oil. For instructions, refer to Checking the engineoil

HOLD RESET FOR SYSTEM CHECKPress and hold the SELECT/RESET stem to select system check whenHOLD RESET FOR SYSTEM CHECK is displayed in the message cen

vehicle’s engine. Refer to Maintenance product specifications andcapacities later in this chapter for more information.Do not use supplemental engine

When the battery is disconnected or a new battery installed, thetransmission must learn its adaptive strategy. As a result of this, thetransmission ma

Auxiliary battery (if equipped)Your vehicle may be equipped with a frame-mounted auxiliary batterylocated on the passenger side frame rail, behind the

• Always dispose of automotivebatteries in a responsible manner.Follow your local authorizedstandards for disposal. Call yourlocal authorized recyclin

When the engine is cold, check thelevel of the engine coolant in thereservoir.• The engine coolant should be at the FULL COLD level, or within theCOLD

WARNING: Do not add engine coolant when the engine is hot.Steam and scalding liquids released from a hot cooling systemcan burn you badly. Also, you c

Add the proper mixture of coolant and water to the cooling system byfollowing these steps:1. Before you begin, turn the engine off and let it cool.2.

Fill your engine coolant reservoir as outlined in Adding engine coolantin this section.Severe climatesIf you drive in extremely cold climates (less th

WARNING: If fail-safe cooling activates, pull off the road assoon as safely possible, and turn the engine off, because theengine may automatically shu

WARNING: Fail-safe mode is for use during emergencies only.Operate the vehicle in fail-safe mode only as long as necessary tobring the vehicle to rest

If the message will not reset or clear when pressing the SELECT/RESETstem, you must address the problem in order to clear the message.PARK BRAKE ENGAG

WARNING: Automotive fuels can cause serious injury or deathif misused or mishandled.WARNING: Fuel ethanol and gasoline may contain benzene,which is a

• FFV fuel tanks may contain zero to 85% ethanol. Any fuel blendscontaining gasoline and ethanol should be treated the same as “FuelEthanol.” To ident

RefuelingWARNING: Fuel vapor burns violently and a fuel fire can causesevere injuries. To help avoid injuries to you and others:• Read and follow all

At the next opportunity, safely pull off of the road, remove the fuel fillercap, align the cap properly and reinstall it. The check fuel caplightor “c

Choosing the right fuelIf your vehicle is a flexible fuel vehicle (FFV), use only UNLEADEDFUEL and FUEL ETHANOL (Ed75–Ed85).If your vehicle is not a f

possible—at least half a tank. Do not add less than five gallons (18.9L)when refueling. You should drive the vehicle immediately after refuelingfor at

If you have run out of fuel:• You may need to cycle the ignition from off to on several times afterrefueling to allow the fuel system to pump the fuel

• Use the same filling rate setting (low — medium — high) each timethe tank is filled.• Allow no more than two automatic click-offs when filling.• Alw

• Anticipate stopping; slowing down may eliminate the need to stop.• Sudden or hard accelerations may reduce fuel economy.• Slow down gradually.• Driv

• Driving on flat terrain offers improved fuel economy as compared todriving on hilly terrain.• Transmissions give their best fuel economy when operat

TIRE PRESSURE MONITOR FAULT (if equipped) — Displayedwhen the Tire Pressure Monitoring System is malfunctioning. If thewarning stays on or continues t

WARNING: Exhaust leaks may result in entry of harmful andpotentially lethal fumes into the passenger compartment.Do not make any unauthorized changes

If the service engine soon indicator remains on, have your vehicleserviced at the first available opportunity. Although some malfunctionsdetected by t

POWER STEERING FLUIDCheck the power steering fluid. Refer to scheduled maintenanceinformation.1. Start the engine and let it rununtil it reaches norma

BRAKE FLUID• E-150/E-250/E-350 Single RearWheel• E-350/E-450 Dual Rear WheelThe fluid level will drop slowly as the brakes wear, and will rise when th

TRANSMISSION FLUIDChecking automatic transmission fluid (if equipped)Refer to your scheduled maintenance information for scheduledintervals for fluid

Low fluid levelDo not drive the vehicle if the fluid level is at the bottom of the dipstickand the ambient temperature is above 50°F (10°C).Correct fl

The transmission fluid should be in this range if at normal operatingtemperature (150°F-170°F [66°C-77°C]).The transmission fluid should be in this ra

High fluid levelFluid levels above the safe range may result in transmission failure.An overfill condition of transmission fluid may cause shift and/o

If an overfill occurs, excess fluid should be removed by an authorizeddealer.An overfill condition of transmission fluid may cause shift and/orengagem

Automatic transmission fluid filterThe Torqshift威 automatictransmission is equipped with aserviceable transmission fluid filterlocated inside the tran

AUDIO SYSTEMSAM/FM stereo system (if equipped)WARNING: Driving while distracted can result in loss of vehiclecontrol, accident and injury. Ford strong

Changing the air filter element1. Disconnect the fresh air inlet tubefrom the radiator support.2. Open the clamp that secures thetwo halves of the air

General• Store all vehicles in a dry, ventilated place.• Protect from sunlight, if possible.• If vehicles are stored outside, they require regular mai

Cooling system• Protect against freezing temperatures.• When removing vehicle from storage, check coolant fluid level.Confirm there are no cooling sys

• If the battery was removed, clean the battery cable ends and inspect.If you have any concerns or issues, contact your authorized dealer.MOTORCRAFT P

MAINTENANCE PRODUCT SPECIFICATIONS AND CAPACITIESItem Capacity Ford part nameFord part number /Ford specificationBrake fluidBetween MIN andMAX on rese

Item Capacity Ford part nameFord part number /Ford specificationEngine coolant(4.6L engine)23.8 quarts(22.6L)Motorcraft威 PremiumGold Engine Coolant(ye

Item Capacity Ford part nameFord part number /Ford specificationEngine oil 6.0 quarts (5.7L)•Motorcraft威 SAE 5W-20Premium SyntheticBlend Motor Oil (US

Item Capacity Ford part nameFord part number /Ford specificationDana Limited Slip AxlefluidM60 (M248)E–250/E–3505.9 pints (2.8L)5,7SAE 90 Hypoid Gear

Item Capacity Ford part nameFord part number /Ford specificationDana conventional axlefluidM60 (M248)E-150/E-3506.2 pints (2.9 L)7SAE 80W-90 PremiumRe

Item Capacity Ford part nameFord part number /Ford specificationFuel tank–all regularand extended lengthvans and wagons33.0 gallons(124.9 L)——Fuel tan

Customer Assistance 238Reporting safety defects (U.S. only) 245Reporting safety defects (Canada only) 245Cleaning 246Underbody preservation 252Mainten

2. AUDIO: Press AUDIO repeatedlyto gain access to the followingsettings:BAL (Balance): Press AUDIO to reach the balance setting.Use/ / SEEK to adjust

Item Capacity Ford part nameFord part number /Ford specificationFuel tank–158 inch and176 inch wheelbase(E-Super Duty)55.0 gallons(208.0L)1Add the coo

ENGINE DATAEngine 4.6L V8 engine 5.4L V8 engine 6.8L V10 engineCubic inches 281 330 415Required fuel87 octane orE85187 octane orE85187 octaneFiring or

IDENTIFYING YOUR VEHICLESafety Compliance Certification Label (complete Ford builtvehicles)The National Highway Traffic Safety Administration Regulati

The vehicle identification number (VIN) contains the followinginformation:1. World manufacturer identifier2. Brake system / Gross VehicleWeight Rating

TRANSMISSION CODE DESIGNATIONSYou can find a transmission code on the Safety Compliance CertificationLabel. The following table tells you which transm

FORD CUSTOM ACCESSORIES FOR YOUR VEHICLEA wide selection of Ford Custom Accessories are available for yourvehicle through your local Ford or Ford of C

•Vehicle tracking and recovery* •Hitch mounted parking sensor*•Bumper mounted parking sensors**Ford Licensed Accessories (FLA) are warranted by the ac

FORD ESP EXTENDED SERVICE PLANS (U.S. ONLY)More than 30 million Ford, Lincoln, and Mercury owners have discoveredthe powerful protection of Ford ESP.

Ford ESP Can Quickly Pay for ItselfOne service bill – the cost of parts and labor – can easily exceed theprice of your Ford ESP Service Contract. With

Ford Extended Service Plan3092011 Econoline (eco)Owners Guide, 1st PrintingUSA (fus)

Setting the clock: Press and hold CLK until the hours begin to flash.Press/ / SEEK to manually increase/decrease the hours.Press CLK again to set the

FORD ESP EXTENDED SERVICE PLANS (CANADA ONLY)You can get more protection for your vehicle by purchasing a FordExtended Service Plan (ESP). Ford ESP is

GENERAL MAINTENANCE INFORMATIONWhy maintain your vehicle?This guide describes the scheduled maintenance required for yourvehicle. Carefully following

parts that are used for maintenance replacement or for the service ofcomponents affecting emission control must be equivalent to genuineFord Motor Com

Company’s specifications, and we stand behind them. Parts installed atyour Ford or Lincoln Mercury dealership carry a nationwide, 12 months,12,000 mil

Multi-point inspectionIn order to keep your vehicle running right, it is important to have thesystems on your vehicle checked regularly. This can help

as well as those things that may require future or immediate attention.The multi-point vehicle inspection is one more way to keep your vehiclerunning

NORMAL SCHEDULED MAINTENANCE AND LOGThe following section contains the “Normal Schedule”. This schedule ispresented at specific mileage (kilometer) in

Miles (x 1,000)* 7.5 15 22.5 30 37.5 45 52.5 60 67.5 75Kilometers (x 1,000)* 12 24 36 48 60 72 84 96 108 120Months* 6 12 18 24 30 36 42 48 54 60Change

Miles (x 1,000)* 82.5 90 97.5 105 112.5 120 127.5 135 142.5 150Kilometers (x 1,000)* 132 144 156 168 180 192 204 216 228 240Months* 66 72 78 84 90 96

Every 15,000 miles(24,000 km)Replace cabin air filter (if equipped)Every 30,000 miles(48,000 km)Replace climate-controlled seat filter (ifequipped)Rep

1. / (Tuner): Press tomanually go up or down the radiofrequency. Also use in menu modeto select various settings.In satellite radio mode (if equipped)

Maintenance schedule logDEALER VALIDATION:P&A CODE:RO#: HOURS:DATE:MILEAGE:DEALER VALIDATION:P&A CODE:RO#: HOURS:DATE:MILEAGE:DEALER VALIDATIO

DEALER VALIDATION:P&A CODE:RO#: HOURS:DATE:MILEAGE:DEALER VALIDATION:P&A CODE:RO#: HOURS:DATE:MILEAGE:DEALER VALIDATION:P&A CODE:RO#: HOUR

DEALER VALIDATION:P&A CODE:RO#: HOURS:DATE:MILEAGE:DEALER VALIDATION:P&A CODE:RO#: HOURS:DATE:MILEAGE:DEALER VALIDATION:P&A CODE:RO#: HOUR

SPECIAL OPERATING CONDITIONSIf you operate your Ford/Lincoln/Mercury vehicle primarily in one of themore demanding Special Operating Conditions listed

Extensive idling and/or low-speed driving for long distances as in heavycommercial use such as delivery, taxi, patrol car or liveryInspect frequently,

Operating in dusty conditions such as unpaved or dusty roadsInspect frequently, service asrequired– Replace cabin air filter (if equipped).– Replace e

Off-road operationInspect frequently, service asrequired– Replace cabin air filter (if equipped).– Replace engine air filter.– Inspect and lubricate s

Special operating condition logDEALER VALIDATION:P&A CODE:RO#: HOURS:DATE:MILEAGE:DEALER VALIDATION:P&A CODE:RO#: HOURS:DATE:MILEAGE:DEALER VA

DEALER VALIDATION:P&A CODE:RO#: HOURS:DATE:MILEAGE:DEALER VALIDATION:P&A CODE:RO#: HOURS:DATE:MILEAGE:DEALER VALIDATION:P&A CODE:RO#: HOUR

EXCEPTIONSIn addition, there are several exceptions to the Normal Schedule. Theyare listed below:Normal vehicle axle maintenance❑Rear axles and power

an audible prompt. Press OK while SONG ALERT is in the display andthe system will take you to the channel playing the desired song. Youcan save up to

COOLANT CHANGE RECORDHot climate oil change intervals❑If operating conditions are normal and you drive your Ford, Lincoln or Mercury vehicle under typ

Engine coolant change logDEALER VALIDATION:P&A CODE:RO#: HOURS:DATE:MILEAGE:DEALER VALIDATION:P&A CODE:RO#: HOURS:DATE:MILEAGE:DEALER VALIDATI

AAccessory delay ...64AdvanceTrac ...189Air cleaner filter ...289–290, 293Airbag supplemental re

exterior ...252instrument panel ...249interior ...250plastic parts

Exhaust fumes ...184FFail safe cooling ...267Flexible Fuel Vehicle (FFV) ...269Floor mats ...

Keys ...83positions of the ignition ...181LLampsbulb replacementspecifications chart ...

replacing the batteries ...79Reverse sensing system ...203Roadside assistance ...210Roll stability control ...

sidewall information ...149snow tires and chains ...162spare tire ...222, 224terminology ...

RBDS: Available only in FM mode. This feature allows you to searchRBDS-equipped stations for a certain category of music format:CLASSIC, COUNTRY, INFO

TRACK/FOLDER MODE: Available only on MP3 discs in CD mode.In track mode, pressSEEK, SEEK to scroll through all tracks onthe disc.In folder mode, press

6. / OK(Play/Pause): This control isoperational in CD/MP3 mode. Whena CD/MP3 is playing, press to pause or play the current CD/MP3. TheCD/MP3 status w

In satellite radio mode (if equipped), there are 18 available presets,six each for SAT1, SAT2 and SAT3. To save satellite channels in yourmemory prese

17. (CD eject): Press to eject aCD.18. CD slot: Insert a CD label sideup in the CD slot.Auxiliary input jack (if equipped)WARNING: Driving while distr

Required equipment:1. Any portable music player designed to be used with headphones2. An audio extension cable with stereo male 1/8 in. (3.5 mm)connec

CONGRATULATIONSCongratulations on acquiring your new Ford. Please take the time to getwell acquainted with your vehicle by reading this handbook. The

5. For safety reasons, connecting or adjusting the settings on yourportable music player should not be attempted while the vehicle ismoving. Also, the

GENERAL AUDIO INFORMATIONRadio frequencies:AM and FM frequencies are established by the Federal CommunicationsCommission (FCC) and the Canadian Radio

CD units are designed to play commercially pressed 4.75 in(12 cm) audio compact discs only. Due to technicalincompatibility, certain recordable and re

• MP3 folder mode represents a folder structure consisting of one levelof folders. The CD player numbers all MP3 tracks on the disc (notedby the .mp3

roof of your vehicle. The vehicle roof provides the best location for anunobstructed, open view of the sky, a requirement of a satellite radiosystem.

Radio Display Condition Action RequiredACQUIRING Radio requires morethan two seconds toproduce audio for theselected channel.No action required.This m

Radio Display Condition Action RequiredNO TEXT Song title informationnot available.Song title informationnot available at thistime on this channel.The

HEATER ONLY SYSTEM(IF EQUIPPED)1. Fan speed adjustment: Controlsthe volume of air circulated in thevehicle.2. Temperature selection:Controls the tempe

MANUAL HEATING AND AIR CONDITIONING SYSTEM(IF EQUIPPED)1. Fan speed adjustment: Controlsthe volume of air circulated in thevehicle.2. Temperature sele

• A small amount of air may be felt from the floor vent regardless of theair distribution setting that is selected.During extreme high ambient tempera

Warning symbols on your vehicleWhen you see this symbol, it isimperative that you consult therelevant section of this guide beforetouching or attempti

HEADLAMP CONTROLTurns the lamps off.Turns on the parking lamps,instrument panel lamps, licenseplate lamps and tail lamps.Turns the headlamps on.Daytim

Flash-to-passPull toward you slightly to activateand release to deactivate.PANEL DIMMER CONTROLUse to adjust the brightness of theinstrument panel and

To adjust the headlamps:1. Park your vehicle on a level surface about 25 feet (7.6 meters) awayfrom a vertical plain surface (3). Check your headlamp

7. On the wall or screen, locate the high intensity area of the beampattern. The left edge of the high intensity area should be even with thevertical

5. Locate the vertical adjuster onthe back of each headlamp, then usea long Phillips #2 screwdriver toturn the adjuster eithercounterclockwise (to adj

Cargo lampsThe dome portion of the cargolamp, the center light, can be turnedon when the headlamp control isrotated fully counterclockwise orwhen any

Examples of unacceptable moisture (usually caused by a lamp waterleak) are:• Water puddle inside the lamp• Large water droplets, drip marks or streaks

Replacing exterior bulbsCheck the operation of all bulbs frequently.Replacing headlamp bulbs (aerodynamic)1. Make sure the headlamp switch is in the o

2. Remove the four screws from theheadlamp assembly and carefullyremove the lamp/bezel.3. Remove the four screws and theretaining ring.4. Disconnect t

To complete installation, follow the removal procedures in reverse order.Replacing side marker bulbs1. Make sure the headlamp control is in the off po

Do not add friction modifier compounds or special break-in oils sincethese additives may prevent piston ring seating. See Engine oil in theMaintenance

Replacing high-mount brake lamp bulbsOn vehicles without a rear headliner, the interior cargo lamp (ifequipped) must be removed from under the high-mo

Replacing stop/turn/tail/side marker/backup lamp bulbsThe stop/turn/tail/side marker/backup lamp bulbs are located in the taillamp assembly. Follow th

MULTI-FUNCTION LEVERWindshield wiper: Rotate the endof the control away from you toincrease the speed of the wipers;rotate towards you to decrease the

TILT STEERING WHEELTo adjust the steering wheel:1. Pull and hold the steering wheelrelease control toward you.2. Move the steering wheel up ordown unt

working, a fuse may have blown. Refer to Fuses and relays in theRoadside Emergencies chapter for information on checking andreplacing fuses.To have fu

INTERIOR MIRRORThe interior rear view mirror has two pivot points on the support armwhich lets you adjust the mirror up or down and from side to side.

To adjust your mirrors:1. Rotate the control clockwise toadjust the right mirror and rotatethe control counterclockwise toadjust the left mirror.2. Mo

Fold-away mirrorsThe mirrors can be manually folded forward or backwards for narrowspaces like driving through an automatic car wash or backing out of

ON: Press to turn on speed control.OFF: Press to turn off speedcontrol.RES (Resume): Press to resume aset speed.SET/ACCEL: Press to set a speedor incr

Reducing speed while using speed controlTo reduce the set speed:• Press and hold COAST until you get to the desired speed, thenrelease. You can also u

Using your vehicle as an ambulanceIf your light truck is equipped with the Ford Ambulance PreparationPackage, it may be utilized as an ambulance. Ford

UPFITTER CONTROLS (IF EQUIPPED)Your vehicle may be equipped withthe Upfitter option package whichwill provide four switches, mountedin the center of t

POSITIVE RETENTION FLOOR MAT (IF EQUIPPED)WARNING: Do not install additional floor mats on top of thefactory installed floor mats as they may interfer

KEYSThe key operates all locks on your vehicle. You should always carry asecond key with you in a safe place in case you require it in anemergency.If

The autolock feature repeats when:• any door is opened then closed while the ignition is in the on positionand the vehicle speed is 9 mph (15 km/h) or

Autounlock featureAfter the autolock feature has locked the doors, the autounlock featurewill unlock all the doors when:• the vehicle has then come to

7. Turn the ignition off. The horn will chirp once to confirm theprocedure is complete.Back cargo door lock (if equipped)The passenger side rear cargo

• The only way to unlock the side or back cargo doors fromoutside vehicle is with the key.For vehicles equipped with manual door locks:• The front doo

• The rear door handle is located inthe rear door below the glass.To open the side or back cargo doors from the inside:1. Unlock the E-Guard Cargo Pro

The remote entry system allows youto lock or unlock all vehicle doorswithout a key.Note: The lock and unlock featureswork when the ignition is in anyp

vehicle has switched to one step unlocking. Repeat the procedure toswitch back to two-step unlocking.Locking the doors1. Press and release to lock all

Event Data RecordingThis vehicle is equipped with an event data recorder (EDR). Themain purpose of an EDR is to record, in certain crash or nearcrash-

2. Do not wipe off any grease on thebattery terminals on the backsurface of the circuit board.3. Remove the old battery.Note: Please refer to localreg

3. Cycle eight times rapidly (within 10 seconds) between the 3 (off)position and 4 (on). Note: The eighth turn must end in the 4 (on) position.4. The

Note: The SecuriLock威 passive anti-theft system is not compatible withnon-Ford aftermarket remote start systems. Use of these systems mayresult in veh

Replacement keysIf your keys are lost or stolen and you don’t have an extra coded key,you will need to have your vehicle towed to an authorized dealer

6. Turn the ignition to the 2 (lock) position, and remove the second keyfrom the ignition.7. After three seconds but within 20 seconds of removing the

FRONT SEATINGWARNING: Reclining the seatback can cause an occupant toslide under the seat’s safety belt, resulting in severe personalinjuries in the e

Adjusting the front manual seat (if equipped)WARNING: Never adjust the driver’s seat or seatback when thevehicle is moving.WARNING: Always drive and r

Using the manual lumbar support (if equipped)The lumbar support control islocated on the inboard side of thedriver’s seat.Turn the lumbar support cont

Press the control to move the seatforward, backward, up or down.REAR SEATSRear captains chair adjust — passenger side onlyPull the lever to adjust the

Quick-release captains chair(7 passenger configuration- second row only)To remove the seat:1. Disengage the lap/shoulder beltfrom the seat by insertin

Note: Including to the extent that any law pertaining to EventData Recorders applies to SYNC威 or its features, please note thefollowing: Once 911 Assi

1. Position the seat to the floormount.2. Pull the seat latch handle downward to lock the seat in position.3. Make sure the safety belt is not twisted

2. Find the clips attached near theends of the lap/shoulder belts.3. Clip the end of the belt to thestationary portion of the shoulderbelt coming out

4. With assistance, pull the LH/RH seat latch release straps (1) (locatedbehind the latch mechanisms) to release the latch from the rear strikers.5. L

4. Engage the front LH/RH hooks to the LH/RH front striker pins.5. After the front LH/RH hooks are engaged to the LH/RH front strikerpins, pull LH/RH

WARNING: It is extremely dangerous to ride in a cargo area,inside or outside of a vehicle. In a collision, people riding inthese areas are more likely

• Front and rear seats2. To unfasten, push the release button and remove the tongue from thebuckle.• Front and rear seatsRestraint of pregnant womenWA

Pregnant women should alwayswear their safety belt. The lap beltportion of a combination lap andshoulder belt should be positionedlow across the hips

How to use the automatic locking mode• Buckle the combination lap andshoulder belt.• Grasp the shoulder portion andpull downward until the entirebelt

WARNING: BELT AND RETRACTOR ASSEMBLY MUST BEREPLACED if the safety belt assembly “automatic lockingretractor” feature or any other safety belt functio

Safety belt warning light and indicator chimeThe safety belt warning light illuminates in the instrument cluster and achime sounds to remind the occup