Introduction 4Instrument Cluster 12Warning and control lights 12Gauges 15Entertainment Systems 19AM/FM stereo 19AM/FM stereo cassette 21AM/FM stereo c
These are some of the symbols you may see on your vehicle.Vehicle Symbol GlossarySafety AlertSee Owner’s GuideFasten Safety Belt Air Bag-FrontAir Bag-
Child booster seatsChildren outgrow a typical convertible or toddler seat when they weigh40 pounds and are around 4 years of age. Although the lap/sho
Types of booster seatsThere are two types of belt-positioning booster seats:• Those that are backless.If your backless booster seat has aremovable shi
Follow all instructions provided by the manufacturer of thebooster seat.Never put the shoulder belt under a child’s arm or behind theback because it e
When installing a child safety seat:• Review and follow the informationpresented in the Air bagsupplemental restraint system(SRS) section in this chap
Installing child safety seats with combination lap and shoulderbelts1. Position the child safety seat in aseat with a combination lap andshoulder belt
3. While holding the shoulder andlap belt portions together, route thetongue through the child seataccording to the child seatmanufacturer’s instructi
7. Pull the lap belt portion acrossthe child seat toward the buckle andpull up on the shoulder belt whilepushing down with knee on thechild seat.8. Al
The SuperCab rear seat has three straps behind the top of the seat backthat function as both routing loops for the tether straps and anchor loops.The
5. Clip the tether strap to the anchor as shown.• Front seat (SuperCab only)• Front seats (Regular Cab) andRear seats (Crew Cab only)If the tether str
Many tether straps cannot be tightened if the tether strap is hooked tothe loop directly behind the child seat. To provide a tight tether strap:1. Rou
Vehicle Symbol GlossaryPower WindowsFront/RearPower Window LockoutChild Safety DoorLock/UnlockInterior LuggageCompartment ReleaseSymbolPanic Alarm Eng
STARTINGPositions of the ignition1. ACCESSORY, allows the electricalaccessories such as the radio tooperate while the engine is notrunning.2. LOCK, lo
Extended idling at high engine speeds can produce very hightemperatures in the engine and exhaust system, creating the riskof fire or other damage.Do
If starting a vehicle with an automatic transmission:1. Make sure the parking brake isset.2. Make sure the gearshift is in P(Park).If starting a vehic
• Turn the key to 4 (ON) withoutturning the key to 5 (START).Make sure the corresponding lights illuminate or illuminate briefly. If alight fails to i
Using the engine block heater (if equipped)Use of an engine block heater isstrongly recommended if you live ina region where temperatures reach-23° C
BRAKESOccasional brake noise is normal. If a metal-to-metal, continuous grindingor continuous squeal sound is present, the brake linings may be worn-o
Parking brakeTo set the parking brake, press theparking brake pedal down until thepedal stops.The BRAKE warning lamp in theinstrument cluster illumina
If you’re parking your vehicle on a grade or with a trailer, press and holdthe brake pedal down, then set the parking brake. There may be a littlevehi
Your vehicle has larger tires and increased ground clearance, giving thevehicle a higher center of gravity than a passenger car.Vehicles with a higher
Do not drive your vehicle until you verify that the brakelampsare working.Always set the parking brake fully and make sure the gearshift islatched in
WARNING LIGHTS AND CHIMESWarning lights and gauges can alert you to a vehicle condition that maybecome serious enough to cause expensive repairs. A wa
N (Neutral)With the gearshift lever in N (Neutral), the vehicle can be started and isfree to roll. Hold the brake pedal down while in this position.(O
2 (Second)This position allows for second gear only.• Provides engine braking.• Use to start-up on slippery roads.• To return to(Overdrive), move the
Understanding the shift positions of the 5–speed automatictransmission (if equipped-Diesel engines only)Your transmission is equipped with an adaptive
D (Overdrive) with Tow/Haul OFFD (Overdrive) with Tow/Haul OFF is the normal driving position for thebest fuel economy. The overdrive function allows
Used for improved traction on slippery roads. Selecting 3 (Third)provides engine braking.2 (Second)Use 2 (Second) to start-up on slippery roads or to
To start the vehicle:1. Make sure the parking brake is fully set.2. Press the clutch pedal to the floor, then put the gearshift lever in theneutral po
Maximum downshift speeds16-speed transmissionShift from: Transfer case position (if equipped)22H or 4H 4LD(Overdrive) -472 km/h (45 mph) 26 km/h (16 m
Removing the keyTurn the ignition off, push therelease lever (located above theignition), then turn the key towardyou and remove the key.REVERSE SENSI
The RSS detects obstacles up to 2meters (6 ft.) from the rear bumperwith a decreased coverage area atthe outer corners of the bumper,(refer to the fig
FOUR-WHEEL DRIVE (4WD) OPERATION (IF EQUIPPED)For important information regarding safe operation of this typeof vehicle, see Preparing to drive your v
Check gage: Illuminates when anyof the following conditions hasoccurred:• The engine coolant temperatureis high.• The engine oil pressure is low.• The
• is operated by a rotary control located on the instrument panel thatallows you select 2WD, 4x4 High or 4x4 Low operation.• uses auto-manual hub lock
N (Neutral) – Only used when towing the vehicle.4L (4WD Low)– For low-speed off-road applications that require extrapower such as steep grades, deep s
Shifting from 4H (4WD High) to 4L (4WD Low)1. Bring the vehicle to a complete stop.2. Depress the brake.3. Place the gearshift lever in N (Neutral) (a
This position should only be usedwhen towing the vehicle.Do not leave the vehicle unattended with the transfer case in theN (Neutral) position. Always
Shifting from 2WD (2WD High) to 4x4 HIGH (4WD High)Rotate the 4WD control to the4x4 HIGH position at speeds up to88 km/h (55 mph).• The electronic shi
4. Move the 4WD control to the 4x4LOW position.5. Hold the shift conditions until theLOW RANGE indicator lightilluminates.6. If the LOW RANGE indicato
Maintain steering wheel control at all times, especially in rough terrain.Since sudden changes in terrain can result in abrupt steering wheelmotion, m
Vehicles with a higher center of gravity such as utility andfour-wheel drive vehicles handle differently than vehicles with alower center of gravity.
Emergency maneuvers• In an unavoidable emergency situation where a sudden sharp turnmust be made, remember to avoid “over-driving” your vehicle, i.e.,
Power is supplied to all four wheelsthrough a transfer case. On 4WDvehicles, the transfer case allowsyou to select 4WD when necessary.Information on t
Safety belt: Reminds you to fastenyour safety belt. A chime will alsosound to remind you to fasten yoursafety belt.Charging system: Illuminates whenth
Once through water, always try the brakes. Wet brakes do not stop thevehicle as effectively as dry brakes. Drying can be improved by movingyour vehicl
When climbing a steep slope or hill,start in a lower gear rather thandownshifting to a lower gear from ahigher gear once the ascent hasstarted. This r
Avoid sudden braking as well. Although a 4WD vehicle may acceleratebetter than a two-wheel drive vehicle in snow and ice, it won’t stop anyfaster, bec
Tires can be damaged during off-road use. For your safety, tires that aredamaged should not be used for highway driving because they are morelikely to
Failure to maintain your vehicle properly may void the warranty, increaseyour repair cost, reduce vehicle performance and operational capabilitiesand
VEHICLE LOADINGBefore loading a vehicle, familiarize yourself with the following terms:• Base Curb Weight: Weight of the vehicle including any standar
Always ensure that the weight of occupants, cargo and equipment iswithin the weight limitations, including both gross vehicle weight andfront and rear
2nd unit bodies are not included in maximum trailer weight ratings. Theweight of the additional “body” must be subtracted from the maximumtrailer weig
F-250 Regular Cab PickupEngine Rear axleratioMaximum GCWR -kg (lbs.)Maximumtrailer weight -kg (lbs.)4x2 with automatic transmission5.4L 3.73 6123 (135
F-250 SuperCab PickupEngine Rear axleratioMaximum GCWR -kg (lbs.)Maximumtrailer weight -kg (lbs.)4x2 with manual transmission5.4L 3.73 6123 (13500) 33
Four wheel drive indicator(if equipped): Illuminates whenfour-wheel drive is engaged.Door ajar: Illuminates when theignition is in the ON position and
F-250 SuperCab PickupEngine Rear axleratioMaximum GCWR -kg (lbs.)Maximumtrailer weight -kg (lbs.)4x4 with automatic transmission5.4L 3.73 6123 (13500)
F-250 Crew Cab PickupEngine Rear axleratioMaximum GCWR -kg (lbs.)Maximumtrailer weight -kg (lbs.)4x4 with manual transmission5.4L 3.73 6123 (13500) 30
F-350 Regular Cab Single Rear Wheel PickupEngine Rear axleratioMaximum GCWR -kg (lbs.)Maximumtrailer weight -kg (lbs.)4x2 with automatic transmission5
F-350 Regular Cab Dual Rear Wheel PickupEngine Rear axleratioMaximum GCWR -kg (lbs.)Maximumtrailer weight -kg (lbs.)4x2 with manual transmission5.4L 3
F-350 SuperCab Single Rear Wheel PickupEngine Rear axleratioMaximum GCWR -kg (lbs.)Maximumtrailer weight -kg (lbs.)4x2 with manual transmission5.4L 3.
F-350 SuperCab Single Rear Wheel PickupEngine Rear axleratioMaximum GCWR -kg (lbs.)Maximumtrailer weight -kg (lbs.)4x4 with automatic transmission5.4L
F-350 SuperCab Dual Rear Wheel PickupEngine Rear axleratioMaximum GCWR -kg (lbs.)Maximumtrailer weight -kg (lbs.)4x2 with automatic transmission5.4L 3
F-350 SuperCab Dual Rear Wheel PickupEngine Rear axleratioMaximum GCWR -kg (lbs.)Maximumtrailer weight -kg (lbs.)4x4 with automatic transmission5.4L 3
F-350 Crew Cab Single Rear Wheel PickupEngine Rear axleratioMaximum GCWR -kg (lbs.)Maximumtrailer weight -kg (lbs.)4x4 with manual transmission5.4L 3.
F-350 Crew Cab Dual Rear Wheel PickupEngine Rear axleratioMaximum GCWR -kg (lbs.)Maximumtrailer weight -kg (lbs.)4x2 with automatic transmission6.8L 3
Speedometer: Indicates thecurrent vehicle speed.Engine coolant temperaturegauge: Indicates engine coolanttemperature. At normal operatingtemperature,
F-350 Regular Chassis Cab Single Rear Wheel (Fifth WheelTowing)Engine Rear axleratioMaximum GCWR -kg (lbs.)Maximumtrailer weight -kg (lbs.)4x2 with ma
F-350 Regular Chassis Cab Dual Rear Wheel (Fifth WheelTowing)Engine Rear axleratioMaximum GCWR -kg (lbs.)Maximumtrailer weight -kg (lbs.)4x2 with auto
F-350 SuperCab Chassis Cab Single Rear Wheel (Fifth WheelTowing)Engine Rear axleratioMaximum GCWR -kg (lbs.)Maximumtrailer weight -kg (lbs.)4x4 with m
F-350 Crew Cab Chassis Cab Single Rear Wheel (Fifth WheelTowing)Engine Rear axleratioMaximum GCWR -kg (lbs.)Maximumtrailer weight -kg (lbs.)4x2 with m
F-350 Crew Cab Chassis Cab Dual Rear Wheel (Fifth WheelTowing)Engine Rear axleratioMaximum GCWR -kg (lbs.)Maximumtrailer weight -kg (lbs.)4x4 with man
F-450 SuperCab Chassis Cab Dual Rear Wheel (Fifth WheelTowing)Engine Rear axleratioMaximum GCWR -kg (lbs.)Maximumtrailer weight -kg (lbs.)4x2 with man
F-550 Regular Cab Chassis Cab Dual Rear Wheel (Fifth WheelTowing)Engine Rear axleratioMaximum GCWR -kg (lbs.)Maximumtrailer weight -kg (lbs.)4x2 with
Preparing to towUse the proper equipment for towing a trailer and make sure it isproperly attached to your vehicle. See your dealer or a reliable trai
Do not connect a trailer’s hydraulic brake system directly to yourvehicle’s brake system. Your vehicle may not have enoughbraking power and your chanc
Trailer towing tips• Practice turning, stopping and backing up before starting on a trip toget the feel of the vehicle trailer combination. When turni
Battery voltage gauge (manualtransmission only): Indicates thebattery voltage when the ignition isin the ON position. If the pointermoves and stays ou
• Maximum speed is 56 km/h (35 mph).• Maximum distance is 80 km (50 miles).If a distance of 80 km (50 miles) or a speed of 56 km/h (35 mph) mustbe exc
The TARC is the weight of the permanently attached equipment that canbe added to the vehicle without violating the vehicle’s Safety ComplianceCertific
Note: Do not exceed the GVWR or the GAWR specified on thecertification label.Removing snowplowAfter removing a snowplow from the vehicle, ensure the v
If you are driving less than 24 km (15 miles) at speeds up to 64 km/h(40 mph) in cold weather, you will not need to worry about bladeposition to provi
GETTING ROADSIDE ASSISTANCETo fully assist you should you have a vehicle concern, Ford MotorCompany offers a complimentary roadside assistance program
Canadian customers who require roadside assistance, call1–800–665–2006.If you need to arrange roadside assistance for yourself, Ford MotorCompany will
This switch is located in the frontpassenger’s footwell, by the kickpanel access cover.To reset the switch:1. Turn the ignition OFF.2. Check the fuel
Standard fuse amperage rating and colorCOLORFuseratingMinifusesStandardfusesMaxifusesCartridgemaxifusesFuse linkcartridge2A Grey Grey ———3A Violet Vio
To remove a fuse use the fuse pullertool provided on the fuse panelcover.The fuses are coded as follows.Fuse/RelayLocationFuse AmpRatingPassenger Comp
Fuse/RelayLocationFuse AmpRatingPassenger Compartment FusePanel Description12 20A* Cigar lighter / OBD II13 5A* Power mirrors/switches14 15A* Daytime
Transmission fluid temperature gauge (automatic transmissiononly): If the gauge is in the:White area (normal) - thetransmission fluid is within thenor
Fuse/RelayLocationFuse AmpRatingPassenger Compartment FusePanel Description32 5A* Radio (start)33 15A* Front wiper34 10A* Brake on-off switch35 10A* I
Fuse/RelayLocationFuse AmpRatingPassenger Compartment FusePanel Description113 30A** Starter motor114 30A** Right-hand power seats115 20A** Trailer to
Spare tire informationYour vehicle may be equipped with a spare tire that can be used aseither a spare or a regular tire. The spare tire is not equipp
Removing the spare tire (with spare tire carrier only)1. The following tools are required to remove the spare tire:• one handle extension and onetypic
3. Fully insert the jack handlethrough the bumper hole and intothe guide tube. The key and lockwill engage with a slight push andcounterclockwise turn
3. Remove the jack, jack handle, lug wrench and spare tire from thestowage locations.4. Use the tip of the lug wrench to remove any wheel trim.5. Loos
• Front (4x2)• Front passenger side (4x4)• Front driver side (4x4)Make sure the jack fits into thenotched area next to the differentialhousing.2003 F2
• RearNever use the front or reardifferential as a jacking point.To lessen the risk ofpersonal injury, do not putany part of your body under thevehicl
The following steps apply to F350 Chassis Cab F450/F550 only:12. Slide the notched end of thejack handle over the release valveand use the handle to s
• Front passenger side (4x4)• Rear14. Insert the jack handle into thepump linkage.15. Use an up-and-down motionwith the jack handle to raise thewheel
AM/FM STEREO1. Seek: Press/ to find thenext strong station down/up thefrequency band.2. Tune: Press/ to manuallychange radio frequency down/up.3. AM/F
The following steps apply to all vehicles:19. Remove the jack and fullytighten the lug nuts in the ordershown.20. Stow the flat tire. Refer toStowing
When a wheel is installed, always remove any corrosion, dirt orforeign materials present on the mounting surfaces of the wheelor the surface of the fr
JUMP STARTING YOUR VEHICLEThe gases around the battery can explode if exposed to flames,sparks, or lit cigarettes. An explosion could result in injury
Connecting the jumper cables1. Connect the positive (+) jumper cable to the positive (+) terminal ofthe discharged battery.Note: In the illustrations,
3. Connect the negative (-) cable to the negative (-) terminal of theassisting battery.4. Make the final connection of the negative (-) cable to an ex
3. Once the disabled vehicle has been started, run both engines for anadditional three minutes before disconnecting the jumper cables.Removing the jum
3. Remove the jumper cable from the positive (+) terminal of the boostervehicle’s battery.4. Remove the jumper cable from the positive (+) terminal of
WRECKER TOWINGIf you need to have your vehicle towed, contact a professional towingservice or, if you are a member of a roadside assistance program, y
An alternative for towing a 4x4 vehicle (with gasoline engine only) with amanual 4WD system is to:• put the transfer case in neutral, then put the 4WD
GETTING THE SERVICES YOU NEEDAt homeFord Motor Company and Ford of Canada have authorized dealerships toservice your vehicle. It is preferred that you
Locks and Security 65Keys 65Locks 65Anti-theft system 67Seating and Safety Restraints 72Seating 72Safety restraints 77Air bags 90Child restraints 99Dr
4. Memory preset buttons: To seta station: Select frequency bandAM/FM; tune to a station, press andhold a preset button until sound returns.5. Power/v
Ford Motor Company of Canada, LimitedP.O. Box 2000Oakville, Ontario L6J 5E41-800-565-3673 (FORD)www.ford.caIf you own a Lincoln vehicle and are away f
In the United States, a warranty dispute must be submitted to theDispute Settlement Board before taking action under the Magnuson-MossWarranty Act, or
The Dispute Settlement Board may not be available in all states. FordMotor Company reserves the right to change eligibility limitations, modifyprocedu
from Ford and Lincoln Mercury dealership management, recognized fortheir business leadership qualities.What the Board needsTo have your case reviewed
Making a decisionBoard members review all available information related to eachcomplaint, including oral presentations, and arrive at a fair and impar
In the CAMVAP program, impartial third-party arbitrators conducthearings at mutually convenient times and places in an informalenvironment. These impa
ORDERING ADDITIONAL OWNER’S LITERATURETo order the publications in this portfolio, contact Helm, Incorporated at:HELM, INCORPORATEDP.O. Box 07150Detro
3. The vehicle is out of service for repair of nonconformities for a total ofmore than 30 calendar days (not necessarily all at one time)In the case o
WASHING THE EXTERIORWash your vehicle regularly with cool or lukewarm water and a neutralPh shampoo, such as Motorcraft Detail Wash (ZC-3–A), which is
PAINT CHIPSYour dealer has touch-up paint and sprays to match your vehicle’s color.Take your color code (printed on a sticker in the driver’s door jam
AM/FM STEREO CASSETTE1. Balance: Press to shift sound tothe left/right speakers.2. Fade: Press to shift sound to therear/front speakers.3. CLK: To set
• Cover the highlighted areas to prevent water damage when cleaningthe engine.• 5.4L V8/6.8L V10 gasoline enginesPLASTIC (NON-PAINTED) EXTERIOR PARTSU
INSTRUMENT PANEL AND CLUSTER LENSClean the instrument panel with a damp cloth, then dry with a dry cloth.• Avoid cleaners or polish that increase the
LEATHER SEATS (IF EQUIPPED, EXCEPT FOR THE KING RANCHF–250 AND F–350 CREWCAB)Your leather seating surfaces have a clear, protective coating over thele
ScratchesIn order to lessen the appearance of certain scratches and other wearmarks, apply conditioner on the affected area following the sameinstruct
Motorcraft Bug and Tar Remover (ZC-42)Motorcraft Extra Strength Upholstery Cleaner (not available in Canada)(ZC-41)Motorcraft Custom Bright Metal Clea
SERVICE RECOMMENDATIONSTo help you service your vehicle:• We highlight do-it-yourself items in the engine compartment for easylocation.• We provide a
• Manual transmission:1. Set the parking brake, depress the clutch and place the gearshift in N(Neutral).2. Block the wheels.Note: Do not start your e
IDENTIFYING COMPONENTS IN THE ENGINE COMPARTMENT5.4L V8/6.8L V10 gasoline enginesRefer to the 6.0 Liter Power Stroke Direct Injection Turbo DieselOwne
WINDSHIELD WASHER FLUIDAdd fluid to fill the reservoir if thelevel is low. In very cold weather, donot fill the reservoir completely.Only use a washer
5. Locate and carefully remove theengine oil level indicator (dipstick).6. Wipe the indicator clean. Insert the indicator fully, then remove itagain.•
4. Tape AMS: In tape mode, pressand hold to activate AutomaticMusic Search (allows you to quicklylocate the beginning of the tape selection being play
3. Recheck the engine oil level. Make sure the oil level is not above theMAX mark on the engine oil level indicator (dipstick).4. Install the indicato
BATTERYYour vehicle is equipped with aMotorcraft maintenance-free batterywhich normally does not requireadditional water during its life ofservice.How
When lifting a plastic-cased battery, excessive pressure on theend walls could cause acid to flow through the vent caps,resulting in personal injury a
• Always dispose of automotivebatteries in a responsible manner.Follow your local authorizedstandards for disposal. Call yourlocal authorized recyclin
When the engine is cold, check thelevel of the engine coolant in thereservoir.• The engine coolant should be at the “cold fill level” or within the “c
Do not put engine coolant in the windshield washer fluidcontainer. If sprayed on the windshield, engine coolant couldmake it difficult to see through
1. Before you begin, turn the engine off and let it cool.2. When the engine is cool, wrap a thick cloth around the coolantpressure relief cap on the c
Fill your engine coolant reservoir as outlined in Adding engine coolantin this chapter.Severe climatesIf you drive in extremely cold climates (less th
How fail-safe cooling worksIf the engine begins to overheat:• The engine coolant temperaturegauge will move to the red (hot)area.• Theand symbol willi
5. Re-start the engine and take your vehicle to a service facility.Driving the vehicle without repairing the engine problemincreases the chance of eng
13. AM/FM: Press to choose afrequency band in radio mode.14. Bass: Press/ todecrease/increase the bass output.15. Treble: Press/ todecrease/increase t
• Avoid inhaling fuel vapors. Inhaling too much fuel vapor of any kindcan lead to eye and respiratory tract irritation. In severe cases,excessive or p
Fuel Filler CapYour fuel tank filler cap has an indexed design with a 1/8 turn on/offfeature.When fueling your vehicle:1. Turn the engine off.2. Caref
Repairs to correct the effects of using a fuel for which your vehicle wasnot designed may not be covered by your warranty.Octane recommendationsYour v
If you have run out of fuel:• You may need to cycle the ignition from OFF to ON several times afterrefueling, to allow the fuel system to pump the fue
For consistent results when filling the fuel tank:• Turn the engine/ignition switch to the off position prior to refueling,an error in the reading wil
Habits• Smooth, moderate operation can yield up to 10% savings in fuel.• Steady speeds without stopping will usually give the best fueleconomy.• Idlin
• Adding certain accessories to your vehicle (for example bugdeflectors, rollbars/light bars, running boards, ski/luggage racks) mayreduce fuel econom
If other than Ford, Motorcraft or Ford-authorized parts are used formaintenance replacements or for service of components affectingemission control, s
3. The fuel cap may not have been securely tightened.These temporary malfunctions can be corrected by filling the fuel tankwith good quality fuel and/
CHECKING AND ADDING POWER STEERING FLUIDCheck the power steering fluid.Refer to the scheduled maintenanceguide for the service intervalschedules. If a
1. Power/volume: Press to turnON/OFF; turn to increase/decreasevolume.2. Scan: Press to hear a briefsampling of all listenable stations,tape selection
CLUTCH FLUID (IF EQUIPPED)Check the clutch fluid level. Refer to the scheduled maintenance guidefor the service interval schedules.Use only a DOT 3 br
TRANSMISSION FLUIDChecking automatic transmission fluid (if equipped)Refer to your scheduled maintenance guide for scheduled intervals forfluid checks
Correct fluid levelThe transmission fluid should be checked at normal operatingtemperature 66°C-77°C (150°F-170°F) on a level surface. The normalopera
If an overfill occurs, excess fluidshould be removed by a qualifiedtechnician.An overfill condition oftransmission fluid may causeshift and/or engagem
Checking and adding manual transmission fluid (if equipped)1. Clean the filler plug.2. Remove the filler plug andinspect the fluid level.3. Fluid leve
Checking and adding transfer case fluid (if equipped)1. Clean the filler plug.2. Remove the filler plug andinspect the fluid level.3. Add only enough
AIR FILTER MAINTENANCERefer to the scheduled maintenance guide for the appropriate intervalsfor changing the air filter element.When changing the air
INFORMATION ABOUT UNIFORM TIRE QUALITY GRADINGNew vehicles are fitted with tiresthat have a rating on them calledTire Quality Grades. The Qualitygrade
The traction grade assigned to this tire is based onstraight-ahead braking traction tests, and does not includeacceleration, cornering, hydroplaning o
Tire inflation informationAll tires with Steel Carcass Plies (if equipped):This type of tire utilizes steel cords in the sidewalls. As such, theycanno
CD: Press to start CD play. With thedual media audio, press CD totoggle between single CD and CDchanger play (if equipped).7. Mute: Press to MUTE play
• Four tire rotation• Five tire rotationYour vehicle may be equipped with atemporary or a conventional sparetire. If the spare tire is different insiz
• DRW – Six tire rotationIf your vehicle is equipped with dualrear wheels it is recommended thatfront and rear tires (in pairs) berotated only side to
Make sure that all replacement tires are of the same size, type,speed rating, load-carrying capacity and tread design (e.g., “AllTerrain”, “Touring”,
MOTORCRAFT PART NUMBERSComponent* 5.4L V8 engine 6.8L V10 engineAir filter element FA-1634 FA-1634Fuel filter FG-986B FG-986BOil filter FL-820-S FL-82
REFILL CAPACITIESFluid Ford Part Name Application CapacityFront axle Hypoid Gear OilSAE 90F-250/350(Dana 60 axle)2.7L (5.8 pints)F-350/450/550(Dana 60
Fluid Ford Part Name Application CapacityFuel tank N/A Mid-ship tank(optional onChassis Cab)71.9L (19.0gallons)Right sidesaddle mountedtank (optionalo
1Your vehicle’s rear axle(s) may be filled with a synthetic lubricant thatmay require a lubricant change. Refer to the scheduled maintenanceguide. Axl
LUBRICANT SPECIFICATIONSItemFord partname orequivalentFord partnumberFordspecificationSpindle bearingHighTemperature4X4 Front Axleand WheelBearing Gre
ItemFord partname orequivalentFord partnumberFordspecificationEngine oilMotorcraft SAE5W-20 PremiumSynthetic BlendMotor Oil (US)Motorcraft SAE5W-20 Su
ItemFord partname orequivalentFord partnumberFordspecificationAutomatictransmission4R100(4–speed)MotorcraftMERCON威 ATF2XT-2-QDX MERCON威Automatictransm
12. Shuffle (CD): Press to playtracks in random order.13. Compression (CD): Press tobring soft and loud passagestogether for a more consistentlistenin
ENGINE DATAEngine* 5.4L V8 engine 6.8L V10 engineCubic inches 330 415Required fuel 87 octane 87 octaneFiring order 1-3-7-2-6-5-4-8 1-6-5-10-2-7-3-8-4-
Dimension Body styleRegularCab 4x2RegularCab 4x4Super Cab4x2Super Cab4x4(5) Overalllength5756 mm(226.6 in)5756 mm(226.6 in)5878 mm(231.4 in)a6289 mm(2
F350–except Crew CabDimension Body styleChassisCab —RegularCabChassisCab —Super CabRegularCab StyleSideSuper CabStyle Side(1) Overallheight1924 mm(75.
Dimension Body styleChassisCab —RegularCabChassisCab —Super CabRegularCab StyleSideSuper CabStyle Side(4)Wheelbase3576 mm(140.8 in)4186 mm(164.8 in)41
DimensionBody styleCrew chassisCabCrew cab-shortboxCrew cab —long box(2b) Track —Rear1 729 mm(68.1 in)a,c/1 803 mm(74.0 in)b,d1 729 mm(68.1 in)a,c/1 8
Dimension Body styleRegularCabChassis 4x2RegularCabChassis 4x4Super CabChassis4x2/4x4Crew CabChassis4x2/4x4(2) Track(Front /Rear)1 736 mm(68.4 in) /1
F550Dimension Body styleRegularCabChassisCab 4x2RegularCabChassisCab 4x4Crew CabChassisCab 4x2Crew CabChassisCab 4x4(1) Overallheight2 076 mm(81.7 in)
Dimension Body styleRegularCabChassisCab 4x2RegularCabChassisCab 4x4Crew CabChassisCab 4x2Crew CabChassisCab 4x4(5) Overalllength5 733 mm(225.7 in)a6
IDENTIFYING YOUR VEHICLECertification labelThe National Highway Traffic SafetyAdministration Regulations requirethat a Certification label be affixedt
Vehicle identification number (VIN)The vehicle identification number isattached to a metal tag and islocated on the driver sideinstrument panel. (Plea
Treble: Press TREB; then pressSEL/ to decrease/increasethe treble output.20. Tune: Works in radio mode only.Press TUNE/ to changefrequency down/up.21.
FORD ACCESSORIES FOR YOUR VEHICLEA wide selection of genuine Ford accessories are available for yourvehicle through your local authorized Ford, Lincol
Travel equipmentAdjustable Towing SystemAuto headlamp system with Daytime Running Lights (DRL)Battery WarmerBed TentBox Aluminum Rack cargo storage sy
BedlinersCarpet floor matsCap (hard, color keyed – Leer supplier branded)Cap (commercial – Leer supplier branded)Cleaners, waxes and polishesDiamond p
Wood trim - interim appliqueFor maximum vehicle performance, keep the following information inmind when adding accessories or equipment to your vehicl
AAccessory delay ...53Air bag supplemental restraintsystem ...90and child safety seats .
plastic parts ...210safety belts ...211washing ...208waxing ...
filter, specifications ...220, 253recommendations ...220refill capacities ...254specifications ...
Infant seats(see Safety seats) ...102Inspection/maintenance (I/M)testing ...238Instrument panel
Power distribution box(see Fuses) ...177Power door locks ...65, 71Power point ...
Towing ...146trailer towing ...146wrecker ...197Traction-l
1. Seek: Press and releaseSEEK/ for previous/nextstrong station, or track of currentdisc.2. Rewind: Press for a slow rewind,press and hold for a fast
280
Fade: Press FADE; then pressSEL/ to shift sound to therear/front speakers.9. Menu: Press MENU and SEL toaccess clock mode, RDS on/off,Traffic, Program
Maintenance and Specifications 215Engine compartment 217Engine oil 218Battery 221Fuel information 229Air filter(s) 246Part numbers 253Refill capacitie
Autostore: Allows you to set the strongest local radio stations withoutlosing your original manually set preset stations for AM/FM1/FM2 . Pressand mom
CD CHANGER (IF EQUIPPED)Your CD changer is in one of the following locations:• Behind the passenger’s seat• In the center console• Under the rear benc
Ensure that the disc holder isevenly inserted and at the samelevel as the magazine (A). The unitwill not operate if the disc holder isnot inserted at
RADIO RECEPTION FACTORSThere are three factors that can affect radio reception:• Distance/strength: The further you travel from an FM station, theweak
CD/CD PLAYER CAREDo:• Handle discs by their edges only. Never touch the playing surface.• Inspect discs before playing. Clean only with an approved CD
HEATER ONLY SYSTEM(IF EQUIPPED)1. Fan speed adjustment: Controlsthe volume of air circulated in thevehicle.2. Temperature selection:Controls the tempe
To aid in side window defogging/demisting in cold weather:1. Select2. Set the temperature control to full heat3. Set the fan speed to the highest sett
Operating tips• To reduce fog build up on the windshield during humid weather, placethe air flow selector in theposition.• To reduce humidity build up
HEADLAMP CONTROLTurns the lamps off.Turns on the parking lamps,instrument panel lamps, licenseplate lamps and tail lamps.Turns the headlamps on.Autola
Foglamp control (if equipped)The headlamp control also operatesthe foglamps. The foglamps can beturned on only when the headlampcontrol is in the, orp
CALIFORNIA Proposition 65 WarningWARNING: Engine exhaust, some of its constituents, andcertain vehicle components contain or emit chemicals known toth
Flash to passPull toward you slightly to activateand release to deactivate.PANEL DIMMER CONTROLUse to adjust the brightness of theinstrument panel and
TURN SIGNAL CONTROL• Push down to activate the leftturn signal.• Push up to activate the right turnsignal.COURTESY/READING LAMPS (IF EQUIPPED)The dome
MAP LAMPSWith trip computerWithout trip computerTo turn on the map lamps, press the control next to each lamp.BULBSReplacing exterior bulbsCheck the o
Function Number ofbulbsTrade numberHeadlamps (aerodynamic) 2 9007Headlamps (sealed beam) 2 H6054Park/turn 2 3157Sidemarker 2 194Tail/stop/turn/sidemar
Handle a halogen headlamp bulb carefully and keep out ofchildren’s reach. Grasp the bulb only by its plastic base and donot touch the glass. The oil f
Replacing front parking/turn signal bulbs1. Make sure headlamp switch is in OFF position and open the hood.2. Remove the two screws andcarefully disen
3. Rotate the bulb socket counterclockwise and remove from lampassembly.4. Pull the bulb straight out of the socket.Install the new bulb(s) in reverse
Replacing roof marker bulbs1. Make sure the headlamp switch isin the OFF position.2. Remove the screw and lens fromthe lamp assembly.3. Pull the bulb
MULTI-FUNCTION LEVERWindshield wiper: Rotate the endof the control away from you toincrease the speed of the wipers;rotate towards you to decrease the
TILT STEERING WHEEL (IF EQUIPPED)To adjust the steering wheel:1. Pull and hold the steering wheelrelease control toward you.2. Move the steering wheel
SAFETY AND ENVIRONMENT PROTECTIONWarning symbols in this guideHow can you reduce the risk of personal injury and prevent possibledamage to others, you
ILLUMINATED VISOR MIRROR (IF EQUIPPED)Lift the mirror cover to turn on thevisor mirror lamps.OVERHEAD CONSOLE (IF EQUIPPED)The appearance of your vehi
5. Place the height adjusters ontothe back of the storagecompartment door. Add as manyadjusters needed to activate thegarage door opener.6. Close the
To tilt the moon roof:• To tilt into the vent position (when the glass panel is closed), pressand hold the front portion of the moon roof control. To
One touch downAllows the driver’s window to openfully without holding the controldown. Press completely down onAUTO and release quickly. Pressagain to
Heated outside mirrors (if equipped)The main mirror glass is heatedautomatically to remove ice, mistand fog and activates when thevehicle is started.N
Clearance lamps (if equipped)Illuminates when the headlamps orparking lamps are switched on.This provides additional visibility ofyour vehicle to othe
POWER ADJUSTABLE FOOT PEDALS (IF EQUIPPED)The accelerator and brake pedalshould only be adjusted when thevehicle is stopped and the gearshiftlever is
3. Press the SET ACCEL controland release it.4. Take your foot off the acceleratorpedal.5. The indicator light on theinstrument cluster will turn on.N
Reducing speed while using speed controlThere are two ways to reduce a setspeed:• Press and hold the COASTcontrol until you get to thedesired speed, t
CENTER CONSOLE (IF EQUIPPED)Your vehicle may be equipped with a variety of console features. Theseinclude:• Utility compartment withcassette/CD holder
SPECIAL NOTICESEmission warrantyThe New Vehicle Limited Warranty includes Bumper-to-BumperCoverage, Safety Restraint Coverage, Corrosion Coverage, and
Selectable featuresEnglish/metric displayPress this control to change the tripcomputer display between metricand English units.Mode controlEach press
2. Press the E/M and MODEcontrols simultaneously. The displaywill illuminate the “AVG” indicator.While the indicator is lit, releaseboth controls to r
CompassThe compass display is contained in the overhead console. The vehicleheading is displayed as one of N, NE, E, SE, S, SW, W and NW.The compass h
Compass calibration adjustmentPerform this adjustment in an open area free from steel structures andhigh voltage lines.For optimum calibration, turn o
TAILGATE LOCK (IF EQUIPPED)Your vehicle may be equipped with atailgate lock designed to preventtheft of the tailgate.• Insert ignition key and turn to
KEYSThe key operates all locks on your vehicle. In case of loss, replacementkeys are available from your dealer.You should always carry a second key w
Childproof door locks• When these locks are set, therear doors cannot be opened fromthe inside.• The rear doors can be openedfrom the outside when the
Your vehicle is equipped with a remote entry system which allows you to:• unlock the vehicle doors withouta key.• lock all the vehicle doors withouta
The UNLOCK feature will work again after:• a door has become ajar,• the ignition is turned to the ON position,• or using the UNLOCKcontrol on your rem
2. Do not wipe off any grease on thebattery terminals on the backsurface of the circuit board.3. Remove the old battery.4. Insert the new battery. Ref
Special instructionsFor your added safety, your vehicle is fitted with sophisticated electroniccontrols.Please read the section Supplemental Restraint
To reprogram the remote entrytransmitters:1. Ensure the vehicle iselectronically unlocked.2. Put the key in the ignition.3. Turn the key from the 2 (L
The battery saver will shut off the interior lamps 30 minutes after theignition has been turned to the OFF position, 10 minutes after if the domelamp
SEATINGNotes:Reclining the seatback can cause an occupant to slide under theseat’s safety belt, resulting in severe personal injuries in theevent of a
40/20/40 split bench seat (if equipped)• Lift the track release bar to movethe seat forward or backward.Ensure the seat is relatched intoplace.• Pull
To gain access to the storage compartment in your armrest, lift the latchto open the lid. The lid cannot be opened in the upright position.Captain’s c
Adjusting the front power seat (if equipped)The control is located on the outboard side of the seat cushion.Your vehicle will only be equipped with on
• Type APress the control to move the seatforward, backward, up or down.• Type BPress the control to move the seatforward or backward.Using the manual
FOLDING UP THE REAR SEATS (IF EQUIPPED — SUPERCABONLY)The rear seatback has a split 60/40 seat. Each seat cushion can beflipped up into the seatback p
All occupants of the vehicle, including the driver, should alwaysproperly wear their safety belts, even when an air bag (SRS) isprovided.It is extreme
Combination lap and shoulder belts1. Insert the belt tongue into theproper buckle (the buckle closest tothe direction the tongue is comingfrom) until
Using your vehicle with a snowplowFor more information and guidelines for using your vehicle with asnowplow, refer to the Driving chapter.Using your v
When to use the automatic locking modeIn this mode, the shoulder belt is automatically pre-locked. The belt willstill retract to remove any slack in t
How to disengage the automatic locking modeDisconnect the combination lap/shoulder belt and allow it to retractcompletely to disengage the automatic l
In the event of a collision, thecolored label (REPLACE BELT)may become visible. If this occurs,the safety belt must be replaced.Whenever the yellowpor
The driver and front outboard passenger safety belt system (includingretractors, buckles and height adjusters) must be replaced if the vehicleis invol
Position the safety belt height adjusters so that the belt restsacross the middle of your shoulder. Failure to adjust the safetybelt properly could re
• 2nd row center seating position (if equipped)The lap belt will not adjust automatically. To fasten, grasp the tongue,and with a continuous motion, p
If... Then...The driver’s safety belt is notbuckled before the vehicle hasreached at least 5 km/h (3 mph)and 1-2 minutes have elapsedsince the ignitio
Reasons given... Consider...“Safety belts don’t work” Safety belts, when used properly,reduce risk of death to front seatoccupants by 45% in cars, and
The BeltMinder feature can be deactivated/activated by performing thefollowing procedure:Before following the procedure, ensure that the following con
8. Confirmation of enabling BeltMinder is provided by:• The safety belt warning light flashing four times per second for threeseconds.• Followed by th
Notice to owners with vehicles equipped with Power Take Off(PTO) capabilityRefer to the Driving chapter for more information and guidelines foroperati
AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM (SRS)Important SRS precautionsThe SRS is designed to work withthe safety belt to help protect thedriver and righ
Never place your arm over the air bag module as a deploying airbag can result in serious arm fractures or other injuries.To properly position yourself
Children and air bagsFor additional important safety information, read all information onsafety restraints in this guide.Children must always be prope
While the system is designed to help reduce serious injuries, it may alsocause minor abrasions, swelling or temporary hearing loss. Because airbags mu
Determining if the system is operationalThe SRS uses a readiness light in the instrument cluster or a tone toindicate the condition of the system. Ref
Turning the passenger air bag off1. Insert the ignition key, turn theswitch to OFF position and hold inOFF position while removing thekey.2. When the
The passenger side air bag should always be ON (the air bag OFF lightshould not be illuminated) unless the passenger is a person who meetsthe requirem
NHTSA deactivation criteria (excluding Canada)1. Infant. An infant (less than 1 year old) must ride in the front seatbecause:• the vehicle has no rear
Transport Canada deactivation criteria (Canada Only)1. Infant: An infant (less than 1 year old) must ride in the front seatbecause:• my vehicle has no
SAFETY RESTRAINTS FOR CHILDRENSee the following sections for directions on how to properly use safetyrestraints for children. Also see Air bag supplem
Commentaires sur ces manuels